Are there transmission problems in a 2006 Jetta?
I would like to start my own 2006 TDI DSG transmission group here on this site. Burnsville Volkswagen and Volkswagen of America refused to allow me to look at the diagnostic test they did on my 2006 Jetta TDI DSG transmission. Volkswagen America paid $118 for the tests and the test generated a 20 page report.
When did the VW Jetta TDI Turbo go bad?
I purchased this 2006 VW Jetta tdi 1.9 turbo diesel new in 2006. After only 50K miles, VW dealership stated the turbo charger went bad and the warranty was initially refused stating it was improper oil used. This was disproved with receipts and still charged $500 of a $2300 bill.
What causes a Volkswagen Jetta to lose power?
My understanding from the mechanic is that this is a common problem, and looking at the Volkswagen tdi forum, that year is particularly bad. This camshaft failure caused a loss of power on the interstate during a heavy traffic time, both times. First incident was on I-240 in asheville midday.
Why does my VW Jetta have an exhaust leak?
Dealership found an exhaust leak in the back of the diesel motor from the egr cooler assembly. The engine was blowing soot in to the engine compartment and it could be heard and smelled through the firewall. This is a diesel so the exhaust contains carcinogenic chemicals.
What kind of transmission does a VW TDI have?
Sunday, July 29, 2012, my husband, Richard, and I were sitting in traffic in Minneapolis, Minnesota and the light turned green, traffic moved and when he pressed on the accelerator the engine sped up as if the transmission were in neutral. The shift selector was in “D†for drive.
Are there any problems with the DSG transmission?
Well, she came back and said that the DSG transmission Mechatronic unit was defective and that Volkswagen America would pay for half the cost of the unit and that we had 30 days to accept the offer. I asked that she send that offer to me in writing.
Are there any problems with the Volkswagen Jetta?
The majority of the problems were minor and were related to the check engine light coming on in colder temperatures. Two much less prevalent but more serious engine problems were the Jetta’s camshaft failure and the engine cutting out while driving. This Volkswagen had almost as many transmission problems as those with the engine.
Is there an aftermarket for a VW Jetta?
Luckily, a vibrant aftermarket exists for TDI’s. In fact, over the past 15-20 years of playing with these cars, so many parts combinations have been tested that—for all intents and purposes—ALH Jetta performance has been nailed down to a science.
What to do if your Jetta won’t start?
If it’s cold and you have a 2009-2012 Jetta CLICK HERE for information. This is by no means a comprehensive list of problems, just some of the most common. Use common sense when doing any testing and be sure that you won’t get run over if the car suddenly and unexpectedly springs to life.
Which is better VW Jetta 01J or 02j?
With the 02J five-speed manual being a much more reliable option than the four-speed 01M automatic offered in the ’99-’03 Jetta TDI’s, most enthusiasts row their own gears. However, as soon as the first nozzle upgrade is performed the OEM clutch can begin to slip.
Is the VW Jetta 2.0L A TDI car?
This 2013 Volkswagen Jetta 2.0L TDI built by XDP functions as a economical daily driver. Currently pulling in over 50 highway MPG and featuring upgrades like an AFE exhaust and intake system it’s easy to see why these cars are a popular commuter of choice for diesel enthusiasts across the country!
What is the DSG code for a 2006 Jetta?
2006 Jetta 1.9 Dsg issue. Code 17160 or p0776. Pressure solenoid or solenoid 2. I have a diagram of the valvebody, it 2006 Jetta 1.9 Dsg issue. Code 17160 or p0776. Pressure solenoid or solenoid 2. I have a diagram of the valvebody, it – Answered by a verified VW Mechanic We use cookies to give you the best possible experience on our website.
When did the Volkswagen Golf TDI come out?
Released back in 2004, this version of the Golf was a big step up from the Mk 4 Golf in terms of performance, road manners and interior look and feel and to us it’s a definite firm favourite.
What causes a VW transmission to lose 5th gear?
Historically, VW transmissions “lose” 5th gear first due to lack of lubrication… If that doesn’t get fixed, you’ll lose the rest of the gears… x2 on Yuri’s statement. I just sold my 3rd transmission since Friday, a very common failure is 5th going out, usually from low fluid.
When does your VW TDI hiccup or hesitate when?
VW 2015 TDI PASSAT, 45 K THROTTLE HESITATION WHEN ENTERING FREEWAY SPEED MERGING WITH TRAFFIC PRESS THE THROTTLE NOTHING THERE ITS FLAT STAYS SAME SPEED.TOOK IT TO VW dealer computer shows nothing , ???? Leo C Huppert on February 15, 2019: 2015 VW TDI PASSAT45 K HAS THROTTLE HESITATION WHEN ENTERING FREEWAY SPEED MERGING WITH TRAFFIC .
Why is my Volkswagen Jetta not shifting into reverse?
The contact owns a 2006 Volkswagen Jetta tdi. The contact stated after having her transmission flushed by the dealer, they notified her that the vehicle would no longer shift into reverse. The vehicle was not repaired.
Are there any problems with the Volkswagen Jetta power train?
Other Power Train related problems of the 2006 Volkswagen Jetta Power Train problems 45 Automatic Transmission problems 39 Clutch problems 39 Transmission Noise problems 18 Manual Transmission problems 14
What kind of transmission fluid does a VW Jetta use?
This article details the necessary steps on how to change VW transmission fluid on 2002-2019 Jetta, Passat, CC, Golf, Beetle, and Eos models that came equipped with the 6-speed DSG transmissions. This transmission type is also referenced as the 02E and 0D9 transmissions, which is the first three letters of the transmissions part number.
Is the Jetta 5 speed a manual transmission?
The early 2005.5-2007 Bentley service manual doesn’t mention this but it’s in a TSB for 2005-2006 New Jetta 5 speed 0a4 : gqq manual transmission (the one on your TDI). This procedure was corrected for the 2005-2010 edition Bentley service manual.
How much gear oil is in a VW Jetta?
1.8 liters (1.9 quarts) of gear oil (the transmission and differential share the same oil in the manual transmission) G52 VW gear oil (22 or 23 mm deep socket for the reverse sensor) VW G52 gear oil has been shown to be thinner than most 75-90w oils.
What is the PRNDL indicator on a VW TDI?
The shift selector was in “D†for drive. The PRNDL indicator on the dash flashed red with all five letters illuminated. Richard tried turning off the ignition and turning it back on and got the same results. He pushed the car to the side of the road and tried the ignition again with the same results.
Why does my Jetta TDI hesitate at 2000 rpm?
Its at high altitude’s thin air, say 8,200′, that our TDI experiences the 2000 rpm puff of smoke and or the mild performance delay at 1,800 rpm. The TDI is here in Georgia, (elevation 1,100″) and not showing any symptoms.
Where to get a new VW Jetta transmission?
Took the Jetta to Jack Ingram in Montgomery Al on a Saturday, Hooked it up to the computer and was told it was a bad valve body and asked to bring it back on Wednesday so it could be inspected by my extended warranty folks….Wednesday comes, car is at Jack Ingram, inspected and now we need a new transmission..go figure!
What kind of problem does a VW Jetta have?
Smelled a sulfur like smell from the engine compartment. Could hear loud blowing sounds on acceleration. Dealership found an exhaust leak in the back of the diesel motor from the egr cooler assembly. The engine was blowing soot in to the engine compartment and it could be heard and smelled through the firewall.
When did I Buy my 2006 VW Jetta?
Bought my 2006 TDI new back in September 2005. Until last week, I couldn’t give anything but high praises for the car and interior finish. I’m a light driver and just recently turned over 86K miles. Always dealer maintained and it just completed its annual checkup about a month ago.
How do you remove transaxle transmission from VW Jetta?
The shortcut I found is to remove the transaxle drive flanges and the transmission will easily drop out of the bottom of the car. Each drive flange is held on by one 6mm allen bolt. Wedge a screwdriver between the flange and transmission to keep the flange from spinning when removing the allen bolt.
How much does a Volkswagen Jetta TDI cost?
Prices for Volkswagen Jetta Tdi s currently range from $5,900 to $19,990, with vehicle mileage ranging from 19,631 to 286,987. Find used Volkswagen Jetta Tdi s near you by entering your zip code and seeing the best matches in your area.
What’s the problem with my VW Jetta TDI?
CARS.COM — Two things have plagued Cars.com’s long-term Volkswagen Jetta SportWagen TDI since we purchased it with 47,000 miles in February: a sticky ignition start-stop button that occasionally wouldn’t let the engine start or stop on command, and a looming pricey transmission service.