Why does my Vito air blower keep getting warm?
Vito Aircon issue! Whenever I turn the Aircon ON, by switching the dial button (compressor), instead of getting cool air, the air coming from the aircon vent were warm as if I just turn the blower on without running the compressor.
What to do when your cooling system is not working?
Start your engine. When the engine is warm, visually watch the coolant in the cooling system to see if it is circulating. Tip: If the coolant is not circulating, then it may need a new water pump. The water pump test should only be done after you verify whether or not the thermostat is faulty.
How to diagnose a cooling system problem-YourMechanic?
Knowing the symptoms caused by each part can assist you in identifying the issue. A failing thermostat is the most common cause of overheating. If it is not opening and closing properly, then it must be replaced by a certified mechanic, such as one from YourMechanic. Step 1: Warm up the engine. Start your vehicle and allow the engine to warm up.
What’s the maximum pressure you can put on a cooling system?
Using the cooling system pressure tester, follow manufacturer’s instructions and apply pressure to the cooling system. Warning: The maximum pressure you should apply is the same pressure noted on the radiator cap.
What causes clutch cable to snap on Vito 109cdi?
Hi, my Mercedes Vito 109CDI has the symptoms of a snapped clutch cable, but after several calls to parts suppliers I have been told that it is a hydrolic clutch system. Are these difficult and expensi… read more Mike
What’s the pressure limit on the cooling system?
The cap is set to 15 psi in most cars and operates like a pressure release valve. The cap acts as a pressure and safety valve. When the cooling system’s pressure exceeds the safety limit, the cap’s safety valve opens to discharge the extra coolant. Vehicles these days have a recovery tank to store that discharged coolant.
How do you open the bonnet on a Vito?
You need to locate the latch and lever it over – which will pop the lock – and then you can open it.. The other way – sometimes worth a try – and will often work on a van – is to go up from underneath…
Are there any problems with the Mercedes Vito?
Mercedes-Benz Vito Problems 1 Alternator difficulties with 2013 Vito. Show the dealer your record of reports and battery replacements to back up your claim and request a goodwill payment to cover the cost of 2 Valuation for 2004 Mercedes-Benz Vito van. 3 Save the heartache. 4 Disco dilemma. 5 A wheelchair conversion. …
Do you need a van for a Vito?
SOUNDS like you need a van. The European vans are way ahead of the Japanese rivals in every aspect except price. They can be tricked up with all sorts of accessories that can look very cool. The Vito is worth considering, as are the VW Transporter and the Renault Trafic.
Why is my air con not working in my Volkswagen?
The main problem is that if the air con system is not used then the system does not get lubricated and consequently will dry out causing common problems such as failed “O” rings and rubber hoses, due to the drying out process. Sometimes we may get a customer in who says that the car is blowing cool air into the cab, but not cold air.
What causes the Mercedes Vito to go limp?
Under-boost can be due to several factors such as intake system air leaks, blocked catalytic converters, EGR problems, and vacuum problems and so on. Since the Mercedes Vito tends to go limp while going uphill, it can be a symptom of blocked catalytic converters. Listed above are some of the Mercedes Vito problems.
What should I do if my Vito engine is not working?
The outlet pipe on the small low pressure pump at the front of the cylinder head should be removed and the engine should be cranked over until the fuel flows out 3. Next the pipes can be refitted and the high pressure pipe at the high pressure pump outlet or at the fuel rail should be cranked again until the fuel flows out
Vito Aircon issue! Whenever I turn the Aircon ON, by switching the dial button (compressor), instead of getting cool air, the air coming from the aircon vent were warm as if I just turn the blower on without running the compressor.
Are there any problems with the Merc Vito?
The Merc Vito in Europe as the Mk1 now is shocking buy with confidence no sorry I bought two and both were good to start then the problems started and as for the newer Mk2 forget it.. my builder mates returned theres. Went for t5’s and the new transit you will need to replace the injectors and good luck doing that job!!!!