Where is the water pump located on a Cummins engine?
The water pump in a Cummins 5.9-liter diesel engine is on the front of the engine, below the cooling fan.
Where is the water pump on a semi truck?
They may also have a fan clutch attached to the fan itself. Most water pumps are mounted on the drive belt end of the engine. For conventional engines, this would be the front most area, for transverse engines, it would be the left side, facing the engine compartment from the from of the vehicle.
Can you drive with a leaking water pump?
its going to make a mess, but should be ok long as you don’t run out of coolant… though it does run the risk of taking out your alternator if it gets too wet… if you can manage(refill) the leak and NOT NOT NOT let it run hot, you can drive it as long as you want to.
How long does it take to replace a water pump on a semi truck?
Water pump replacement takes about 3 hours on average. You may save money by purchasing the pump yourself and having it installed by the technician, but proceed with caution and ensure that the parts are purchased from a trustworthy supplier.
Is there any water loss in a Cummins ISX?
Changed coolant filter, changed surge tank (old one was cracked, replaced with Dorman), coolant filter valve o-rings, new surge tank fill cap (genuine Paccar), put a hose from the pressure cap nipple to the frame so i can see any evidence of water loss- None so far.
Can a bad water pump cause coolant to leak?
Finally, Coolant leaking under the part of the vehicle that houses the water pump could indicate a bad water pump. If coolant drips are found, an under-hood inspection must be performed.
Is there a leak in the ISX surge tank?
There is not an external leak anymore, it previously had a leak at the coolant filter, filter valve o-rings, and then the fill cap on the surge tank. Now it’s losing more coolant. There isn’t any white smoke. The EGR cooler is not original, but I don’t have any info on when that was changed.
What should I do if my water pump is leaking?
Overheating will damage the seal and impeller inside the water pump. Use a quality water pump to keep your cooling system working at optimal condition for a longer period. When replacing a water pump run by a timing belt; always replace the timing belt at the same time; especially if the water pump was leaking.