Where is the crankcase breather on a car?
The crankcase breather is generally mounted on the exterior of the engine case, often with a small “cage” around it to protect it but still allow access.
Why are the handlebars on a Kawasaki Kz1000 coated?
Aluminum handlebars are coated to prevent corrosion and the coating can block electricity conduction. The solution – use sandpaper (300 or 400 grit works fine) and scuff up the bar where it fits in the riser and also clean the paint off the riser. Above you can see the aluminum handlebar in the triple clamp.
Can a crankcase breather cause an oil leak?
This leads to blown seals and gaskets, causing oil leaks. After cleaning the crankcase breather, the blown seal or gasket will have to be located and replaced before use of the mower is resumed.
What to use to clean Kawasaki Kz1000 triple clamp?
The solution – use sandpaper (300 or 400 grit works fine) and scuff up the bar where it fits in the riser and also clean the paint off the riser. Above you can see the aluminum handlebar in the triple clamp.
How to tell if your crankcase breather is bad?
White or blue smoke coming from the exhaust pipe is a strong indicator that the crankcase breather is clogged. Thick black smoke usually indicates the problem is more advanced, and built-up pressure is forcing oil into the cylinder where it burns off and sends black smoke through the exhaust.
What causes oil leak in lawn mower crankcase breather?
Oil leaks are the most common symptom of a defective lawnmower crankcase breather. Over time, filters may become clogged with dust and other debris, which restricts airflow and allows pressure to build.
What are the symptoms of a bad crankcase vent filter?
3. Decrease in engine performance. A decrease in engine performance is another symptom of a potential problem with the crankcase vent filter. If the filter becomes clogged and causes any vacuum leaks, this may cause a decrease in engine performance due to the disturbance in the air-fuel ratio.
Where is the crankcase breather on a Briggs and Stratton lawn mower?
Briggs & Stratton lawnmowers will typically have the breather mounted near the rear of the engine, but other makes may have the breather mounted on the right or left side or even at the front of the engine. Oil leaks are the most common symptom of a defective lawnmower crankcase breather.