Is there a power loss on a Detroit 60 series?
I have a power loss… I have a power loss on a Detroit 60 series engine its in a freightliner classic 2003.
When does a Detroit 14L lose all power?
I have a detroit 14l, it starts and runs just fine. Idles fine, no missing. Hold above 1500rpm and after about 60 seconds it loses all power abruptly. No missing or fuel starve …
What causes a Detroit 60 series engine to derate?
Low boost, exhaust leaks before the turbo, boost leaks, and/or bad turbo Air in the fuel due to injector o-rings, crack in the suction line, etc etc. Faulty sensor- Usually followed by a check engine light, and the engine will derate.
What should the PSI be on a Detroit 60 series engine?
1200-1300, you should have 30-45 psi 1800-2100, you should have 65-80 psi If the fuel pressure is high, I would suspect a plugged fuel filters or faulty fuel pressure regulator. If the guage is really bouncy, and unstable, especially under boost, then compression could be leaking past the injector o-rings.
What makes a Detroit Series 60 engine hard start?
Low miles occasionally, pet and rider policy is a little high. Sometimes have to wait for a load If you have the clear glass davco type fuel filter it also has a ck. valve on fuel line that goes bad, all it takes is a small bit of trash in ck. valve to make it louse prime .
Are there any problems with the series 60 engine?
We’ve briefly discussed some of these problems in our Series 60 spotlight, but we’ll dive into them a bit more fully here. It Still Runs also mentions a few of these issues. Cold starts, aptly named for starting your engine in cold temperatures, have given Series 60 engines trouble. They can lose their prime and not start properly.
https://www.youtube.com/watch?v=y84iXqaa8jw
What kind of engine does a Detroit 60 have?
I own a 1993 kenworth with a series 60 detroit , 12.7 / 400hp. I own a 1993 kenworth with a series 60 detroit , 12.7 / 400hp. How can i maximize the power output and fuel mileage on an engine of … read more
What should the PSI be on a Detroit 60 series?
You should have around 20 psi at idle and around 70 at full throttle. If you had egr issue, i would figure it would be logging a 39 code in the ecm.If you had a sucking air in the fuel system, truck will normally be hard to start and the pressure would be low.
https://www.youtube.com/watch?v=CH6kP7jwhh0
Why is my Detroit 60 series running flat?
Here is my problem I have a 12.7 detroit 60 series and it seems like it just doesn’t have any power. The turbo whistle is very faint. I have a little bit of black smoke out of pipe when i accelerate onto the interstate. I had a brand new crate model put in 2008 and they didnt change the turbo. I believe this is the original turbo.
How to check Detroit Diesel Series 60 ECM?
Detroit series 60 ECM – Answered by a verified Technician. Here is diagram of the vehicle harness plug and the pin outs. graphic. Here is a I am going to attach a diagram of the engine harness also, so you can check the SRS and TRS wires. Series 40 detroit Diesel engine in a motor home. Ddec Iv Ecm Wiring Diagram. Source.
What is wiring diagram for Detroit Diesel engine?
The wiring diagrams cover both the Series 60 engine harness and Series 60 vehicle interface harness. Back to Detroit Diesel Engine Information. DDEC I, DDEC II, and DDEC III & IV Schematics.
What causes a Detroit Diesel Series 60 to overheat?
This can indicate a coolant leak. If there is such a leak, you might also notice lower coolant levels in your engine, but things otherwise appear normal. This can lead to an overheated engine. Operators often find that they experience issues with their EGR system on their 14L Series 60 in particular.
Are there any problems with my 2004 Columbia?
Not open for further replies. I have a 2004 Columbia with a 60 series Detroit and for the last two years there has been an intermitent electrical problem. The tach and speedometer will go to zero while the warning beeper is screaming, the shift indicator will go blank, sometimes the truck and traliler ABS indicator sounds as well.
What’s the turbo pressure on a Detroit Diesel?
It is idling roughly, doesnt have as much power as before, slow building turbo boost pressure from 16psi to maximum 24psi. Sometimes it works for about an hour just fine, pulls good, boost pressure is at 28psi.
What are the codes for Detroit Diesel Series 60?
Detroit Diesel Series 60 Engines only; Codes 43, 44,45,51 and 53 are critical codes and if they are shown; the Stop Engine Light will come on which causes the engine protections to engage and your engine may shut down.
Are there any problems with the Freightliner Columbia?
Discussion in ‘ Freightliner Forum ‘ started by raclown, Feb 1, 2009 . Not open for further replies. I have a 2004 Columbia with a 60 series Detroit and for the last two years there has been an intermitent electrical problem.
What kind of engine is Detroit Diesel Series 60?
Almost by definition, truckers have always been practically obsessed with engine reliability fuel mileage. To meet the demand for a new type of engine that would help usher turbo-diesels into this millennium, Detroit Diesel (a subsidiary of Chrysler AG) introduced the Series 60 as its industry trump car.
Why is my Series 60 diesel engine not running?
However, it took Detroit about 10 years to realize that the engine’s idle speed was not fast enough to operate the oil pump. As such, many older (pre-1997) engines have had lower engine bearings replaced more than once due to oil starvation. When it comes to power, the Series 60 tends to favor the higher end of the RPM band.
The 12.7 was a pre-egr engine. The 14L was the one with the EGR Mommas_money_maker Thanks this. Thats right! the 12.7 dont need no stinkin’ egr! LOL I believe you have a turbo issue and like SHC is saying fix it now or it will go boom.
How many horsepower does a Detroit 60 have?
I changed the one fuel filter twice.I … read more Vocational, Technical or Tra… Detroit 60 350 hp in 93 volvo used as farm semi. Way down on power. will not pull empty trailer in high gear! So far: 1 Turbo spins free by hand and feels smooth, nice etc.
Is there a charge for Detroit 60 service?
There is no charge for this service, but standard message and data rates may apply. Could be as simple as a clogged up fuel filter. That is the problem I ran into. Yep, the turbo would be bad. I had a 12.7 I ran for 7 years and every 200k miles I had to put a new turbo on the truck.
How to increase horsepower on a Detroit Diesel Series 60?
Upgrade to the latest version of the Detroit Diesel Electronic Control System. The DDEC (IV) not only allows owners to run diagnostics on the engine, it also permits the changing of the horsepower settings. Go to your local dealer to have them download the current software to your engine’s computer.
When did I overhaul my Detroit S60 diesel?
I have overhauled my Detroit S60, year 2000 I put new pistons, new head, new fuel pump, new injector, new harness, new ecm and it does not work properly. It is idling roughly, doesnt have as much power as before, slow building turbo boost pressure from 16psi to maximum 24psi.
Which is better Detroit Series 60 14L or DPF delete?
You may also be searching for cummins detroit series 60 14l egr delete or detroit dd15 dpf delete. We do our best to bring you from google to our website offering cleaner alternative options for detroit diesel dpf delete.
How to delete the Detroit DD15 S60 DDEC?
DETROIT DD13 DD15 S60 DDEC DPF EGR DEF DELETE BYPASS ALTERNATIVE SOLUTIONS PROGRAMMING Detroit Diesel Type Delete Alternative Solutions Series 60 DDEC4 EGR VGT Series 60 DDEC5 EGR VGT Series 60 DDEC5 EGR VGT Series 60 DDEC6 DPF EGR VGT