What is the hydraulic system on a Jaguar XK8?
The hydraulic system is push/push system that means that two hydraulic lines are attached to both lift rams and the roof latch ram so when you operate the roof manually additional fluid can and in most situations will seep out. So have a clean dry rag in the car for any leakage that might take place.
What to do if your Jaguar XK8 roof is not closing?
Lubrication of the ram shafts can be done by spraying WD40 on a rag and rub it on the ram shaft and this can be done when the roof is in the closed position. The roof goes up to the latch but the latch does not grab the roof and close or the latch opens and the roof will not pull back to open. First check the fluid level and the petcock closed.
Why are my Ram seals failing on my Jaguar XK8?
With the hoses, pump pressure is the most common problem and also contributes to the ram seals failing but the lack of lubrication on the ram shafts will also add to the ram seals becoming dislodged. This next link will cover what I have found when investigating the hydraulic failures on the XK8.
Where are the passages in a Jaguar engine?
The passages are buried in the pump body and I will use compressed air to trace them out. They are using a pump that operates off non-concentric rings, sort of like a wankel engine. Pressure is created when the rings come together and suction when they are apart.
Can a Jaguar XK8 be converted to a V8?
LS1 LSx V8 Conversion for Jaguar XK8 XKR 97-02 (Convertible & Coupe) Building on our experience from the XJ8 LS1 conversion, we took on a similar project with a 98 XK8 convertible. This was a local one owner, 97k original miles car with a skipped timing chain that trashed the engine. Bad for them, good for us.
How to upgrade the convertible top on a Jaguar XK8?
Jaguar XK/XKR Hydraulic Convertible Top Upgrade Instructions Background Information: This upgrade kit is designed for the Jaguar XK8/XKR model years 1996-2005. The automatic convertible top in these model years is operated by a hydraulic system manufactured for Jaguar by the Power Packer company.
How old is the 1997 Jaguar XK8 convertible?
Thanks For Signing Up! This ’97 convertible is 24 years old, has 83k miles, and except for a new electrochromic rearview mirror, driver’s side seat control module, a vacuum line and a third set of Pirellis, is 100% original… Read full review A mechanical disaster.
The hydraulic system is push/push system that means that two hydraulic lines are attached to both lift rams and the roof latch ram so when you operate the roof manually additional fluid can and in most situations will seep out. So have a clean dry rag in the car for any leakage that might take place.
What to do about roof latch on Jaguar XK8?
Lubrication of the ram shafts can be done by spraying WD40 on a rag and rub it on the ram shaft and this can be done when the roof is in the closed position. The roof goes up to the latch but the latch does not grab the roof and close or the latch opens and the roof will not pull back to open.
What causes a slow leak on a Jaguar XK8?
A slow leak could be caused by a hose connector beginning to fail or a ram shaft seal that has been dislodged all due to high pressure. When you see a green fluid in the header light or in the rear tire wheel well (it would be a moist area forward of the tire) it is a sign of a leak.
What are the switches on a Jaguar roof?
It also has three switches in the header, top ready to latch switch, top latch closed and top closed switch. Now I am going to attach a link to a TSB from Jaguar that will go into every detail of the roof operation that can be a little overwhelming but it will be a helpful tool when troubleshooting.
What kind of oil leak does An XK8 have?
My 2001 XK8 convertible sprang a hydraulic oil leak under the roof latch, dripping down through the ultrasonic sensor screen, etc. Very messy & also disturbing given my car is pampered (only 33k miles). I do drop the top a lot here in Atlanta since the weather is ideal for convertibles. But come on!
Lubrication of the ram shafts can be done by spraying WD40 on a rag and rub it on the ram shaft and this can be done when the roof is in the closed position. The roof goes up to the latch but the latch does not grab the roof and close or the latch opens and the roof will not pull back to open.
A slow leak could be caused by a hose connector beginning to fail or a ram shaft seal that has been dislodged all due to high pressure. When you see a green fluid in the header light or in the rear tire wheel well (it would be a moist area forward of the tire) it is a sign of a leak.
How to flush hydraulic fluid on Jaguar XK8?
Flush Hydraulic Fluid to Fix Problems Opening/Closing Convertible Top on Jaguar XK8 Problem Description Problems when opening or closing the convertible top may be fixed by flushing the hydraulic fluid and replacing it with an improved Jaguar fluid.
My 2001 XK8 convertible sprang a hydraulic oil leak under the roof latch, dripping down through the ultrasonic sensor screen, etc. Very messy & also disturbing given my car is pampered (only 33k miles). I do drop the top a lot here in Atlanta since the weather is ideal for convertibles. But come on!
Lubrication of the ram shafts can be done by spraying WD40 on a rag and rub it on the ram shaft and this can be done when the roof is in the closed position. The roof goes up to the latch but the latch does not grab the roof and close or the latch opens and the roof will not pull back to open. First check the fluid level and the petcock closed.