Should I replace AC drier?
The receiver/drier should be replaced any time the system is opened for service, and most compressor warranties require it. Additionally, the filter inside the receiver/drier could be restricted by debris that may have been inside the system. This could diminish refrigerant and oil flow.
What to do if your a / C compressor is not working?
It is never engaged until after the truck starts if it’s working properly. Just to be sure it’s the compressor, take the belt off and then try spinning it by hand with the key off. If the clutch is good, it should just spin free and the compressor itself will not turn.
What happens if I Fill my compressor with R134A?
Just filling your compressor with the R134A would cause your compressor to work harder due to the increased pressure and eventually create a leak to seal. But that’s the second thing to worry about. The first thing is that your factory compressor should be good enough to work correctly.
What do you need to change a / C compressor?
You’ll need to change the compressor and clutch as an assembly, accumulator/drier, and orifice tube. You’ll need some PAG refrigeration oil to lube the o-rings when you put it back together, refrigerant, gauges, and a vacuum pump.
Can a dryer be replaced with an AC compressor?
While a lower estimate may seem appealing, it may not include a replacement AC dryer, which can wreak havoc on your AC system. At Rivergate Muffler & Auto Repair, we will always make the necessary repairs to your AC dryer when working on your compressor.
Can a receiver dryer be drained of oil?
Typically you’ll want to change the receiver dryer along with the compressor. The dryer cannot be drained of oil, so you have to make an assumption that 2 ounces are held in side the dryer.
How do you replace the refrigerant in an AC compressor?
Replace the refrigerant tubes’ O-rings and lubricate with the proper oil. Reinstall the refrigerant lines and put the belt back on the pulley. Pull a vacuum through the system to eliminate any residual atmospheric air or moisture.
Where is the dryer located in an AC system?
The AC dryer, also known as the receiver, filter or dehydrator, is located in the high-pressure section of your AC system. The dryer looks like a series of small metal canisters and can usually be found in the plumbing between the condenser outlet and the expansion valve inlet. The AC dryer is an integral part of the AC system in your vehicle.
Are there any problems with the Rialta air conditioner?
In what has to be the most poorly designed air conditioning compressor ever used in an automotive application, Rialta owners have had to bear the cost of solving this problem. There are two distinct problems noted with the “dash air” of the Rialta.
Is the coach side door on a Winnebago Rialta?
The VW EuroVan comes with electric locks for the cab front doors. Winnebago cuts into this circuit to provide power for the electric lock function for the coach side door. While there have been a few problems on the VW side of the design, the Winnebago design for the coach side door has been a major headache for Rialta owners.
What kind of battery does a Rialta coach use?
Even then, the 12v coach batteries provide power for lights, TVs, furnace, computers, etc. The generator set used in the Rialta is the smallest and least expensive model built by the manufacturer.