How do you check a fan thermostat?
How to Test a Car Fan Thermostat Switch
- Place a small sauce pan on the stove and fill it with one cup of water. Place the thermostat switch in the sauce with the terminals turned up.
- Place the thermometer in the sauce pan so you can read it as the temperature increases.
How does a bike radiator keep the motor cool?
Travelling through the tubes within the radiator cools the fluid thanks to the flow of cool air than should be travelling through them as you move. Once through, the fluid travels back to the pump before returning to the same journey, endlessly circulating to keep the motor on song.
Why does a motorcycle have an air cooling system?
Motorcycle Engine Cooling System – Air Cooled Engine Air cooled engine therefore air cooling is very frequent and popular as motorcycle engine cooling system. Air cooling system is very simple in construction and very much cost effective. So lower capacity and simple construction motorcycle very widely uses air cooling feature.
How does a cool running system work on a bike?
The liquid is pumped round the cylinder, or cylinders, where it gathers their heat and once up to temperature, the thermostat valve directs the fluid to the top of the radiator. Travelling through the tubes within the radiator cools the fluid thanks to the flow of cool air than should be travelling through them as you move.
How does a liquid cooled motorcycle engine cool?
The radiator is attached facing the high airflow line and also have an additional cooling fan to make the liquid forcefully cool inside the radiator. In the liquid cooled motorcycle engine there is a close loop of liquid coolant ( Source ). There also attached a mechanical pump which circulates the liquid coolant within the loop.
Why is the fan still running on my Kawasaki Teryx?
After a long ride in the heat, when the Teryx comes to a stop and the ignition key is removed, the fan should still be running to dissipate the heat. If the fan tops as soon as the key is removed, this is a clear indication that there might be something wrong with the fan relay.
What kind of fan does a Kawasaki MULE use?
I found a fan motor out of a 1993 Suzuki Aerio that fit for $10 from my local junkyard (Too stubburn and cheap to give Kawasaki $300 for the whole assembly). The fan works when I jump it but it didnt go on when I heated the engine up.
Why does my Kawasaki MULE engine get hot?
There is a switch in the radiator that controls the fan, if no coolant is in contact with the sensor then your fan wont come on and the engine gets hot. To solve this you have to run the Mule until it gets warm and then park it on a hill with the nose up in the air.
Why does my Kawasaki Teryx clutch keep squealing?
When the clutch system on the Teryx is still in good condition, these symptoms point to a bad belt that needs replacement or proper adjusting. It is reported that the drive belt on the Teryx is quite tight, and the squealing will eventually occur, especially on inclines.