Can a CV axle be replaced on a VW Passat?
Prevent any roadway mishaps by replacing your Passat drive axle with a new one from AutoZone before it breaks and renders your VW inoperable. Your Passat has taken you everywhere you want to go, but your CV axle has worn out, due to constant use.
How to replace the CV joint boot on a VW Passat?
STEP 1: Loosen the five lug nuts that fasten the rim and remove the center VW cap. Then remove the center bolt and jack up the car to remove the tire. This is the left outboard CV Joint Boot. The boot is actually torn to left side of the smaller CV Joint Boot band (clamp) groove (removed in this image) from the top.
How do you remove an axle from a VW?
Axle from the car needs no clamp to be removed. If auto theres no bolts on the trans it just slides out i believe. There are four bolts holding the axle in. Three nuts for the lower control arm come out so the arm swings down. One large axle bolt.
How do you remove a CV joint axle?
If auto theres no bolts on the trans it just slides out i believe. There are four bolts holding the axle in. Three nuts for the lower control arm come out so the arm swings down. One large axle bolt. That’s it. then you take a prybar and put itbetween the trans case and the axle shaft and use a hammer to hit hte bar.
How to remove drive axle from transmission drive flange?
– Disconnect drive axle from transmission drive flange. – Mark installation position of ball joint bolts on control arm. – Remove bolts (arrows). – Press drive axle out.
What’s the best way to replace a CV axle?
– Coat contact surface of twelve-point nut with oil and screw on as far as possible. – Pull outer joint into wheel hub until outer joint is in position. – Connect ball joint to control arm. – Use new bolts. – Align bolts to markings. Use new bolts! Use new bolts! – Lower vehicle until wheels touch ground.
Is the VW Passat the same as Audi A4?
The CV joint was clicking so it was replaced with a high quality rebuilt axle. The model shown is a B5 VW Passat which is the same as similar generation Audi A4, A6, A8 but these tips can apply to most cars. Loading…
How to remove and replace an inner CV joint?
How to remove and replace an inner CV joint. VW Passat shown but German cars disassembly similar – YouTube
Where can I get a new CV axle?
If you hear clunking noises after you shift from drive to reverse or feel vibrations throughout your vehicle, you might want to consider a new drive shaft. Drop by your local AutoZone to check out our extensive selection of CV axles to find the best replacement for your ride.