How to remove window trim on Volkswagen Golf?
Insert door window -9- into door -1–arrows- and insert door window into slot of window regulator guide. Make window -1- engage in window regulator -2- by pressing slightly from above. Then perform remaining installation in reverse order of removal. Carry out functional test before fitting door trim.
How do you repair a VW Golf door?
Screw 5 mm bolt (approx. 70 mm long) into spreader pin -3-, and pull bolt together with spreader pin out of spreader plug -4-. Screw an 8 mm bolt (approx. 80 mm long) into spreader plug -4-. When screwing bolt into spreader plug, do not apply excessive pressure on plug. It otherwise falls inwards into door.
How do you take a car door off a VW?
After all the screws are out, the door will not just fall off. It is held in place by a punch of clips. You need to pull out on the bottom of the panel until the bottom is no longer connected, then push up to allow the door to pop off the upper clips and up off of the lock and out of the window slot.
Where are the screws on a Volkswagen car door?
Undo the power clip and take out several screws holding the bottom part of the assembly in place. You will need a T20 Torx bit to remove 3 screws at the bottom of the door panel, hidden under the edge as pictured. There is also one other sneaky screw on the inside edge of the door, near the top.
How do you remove glass from front door?
Loosen the two T30 (or 10mm bolts) screws, do not remove them; otherwise, the back part of the clamp will fall into the door Remove the glass by pulling the back part of the glass up and forward and as it comes up it will come past the frame of the door.
Is there a quarter glass in the rear door?
A quarter glass is never in the rear door. Quarter glass windows are either stationary or retractable, depending on the window next to which they are mounted.