What are the symptoms of a VW Transporter T5 problem?
To identify the problem the symptoms listen out for a rattle on the engine on idle, this can be fairly subtle at first but gradually builds the further the part is worn. Other symptoms can sound like a slight misfire or slight stutter when you are pulling away. Raise the clutch slowly in first gear and feel out for an unexpected judder.
What causes central locking on a VW Transporter T5?
Again, your coolant level light should light up on the dash to give you a bit of warning. Ignore the low coolant light at your peril as your engine will eventually overheat and fail. On older higher mileage T5’s it is fairly common to hear of electrical problems that cause the central locking to play up.
What are the symptoms of a Volvo transmission problem?
Volvo transmission problem symptoms vary. A complete list of possible symptoms includes: Hard shifting between gears or hard downshifts. Volvo does not move when placed in Drive or Reverse. The engine revs up before going into the next gear. Transmission stuck in gear. Common fault codes are TCM-002A, TCM-002B, P0733, P0734.
When did the VW Transporter T5 come out?
It is important to point out that the VW T5 has been on the market since 2003 and rapidly approaching the 20 year mark. Many of the T5 models that we see on the UK roads are now approaching and even exceeding 200,000 miles. Therefore don’t let this guide of VW transporter T5 problems put you off owning one!
What happens when your Volkswagen suddenly loses power?
Today at 110 KMpH heading up a hill I had a sudden loss of power, the revs were coming up but I had no drive. I knocked itout of drive and back in and the power came back but before this it was just like the car as coasting and slowing on the hill.
Why does my VW T4 keep losing power?
Since I’ve had it, it’s had the dreaded limp mode issue. It’s been to three VW specialists so far and none of us can find why it’s doing it. So far, in 8 months, it’s had: Coolant temp sensor New injector & others cleaned Service Boost pressure… HELP! No power pulling away in 1st gear!!??
What causes a VW transmission to lose 5th gear?
Historically, VW transmissions “lose” 5th gear first due to lack of lubrication… If that doesn’t get fixed, you’ll lose the rest of the gears… x2 on Yuri’s statement. I just sold my 3rd transmission since Friday, a very common failure is 5th going out, usually from low fluid.
Is there a problem shifting into 5th gear?
After taking the cover off and inspecting 5th gear, it appears in good shape still – wet with oil everywhere, and no signs of any heat. Both the 5th driven gears, and the clutch gear are in good shape, and the clutch gear is not binding or anything, so I don’t see a problem there.
What makes a VW Transporter T5 leak coolant?
When the seals leak it usually dumps coolant into the engine oil (making it look like a failed head gasket) which is bad news if you don’t spot it early. Running low on coolant frequently would be an indication of early failure.
What to do about rust on a VW Transporter T5?
If caught early you can wire brush it clean and lather on a good thick coat of rust inhibitor + top it with a decent quality paint. Another area to watch out for rust is on the barn door models of T5. The paint cracks over time and the rust tends to take hold along the bottom of the doors.
What should I do about my VW Transporter?
A good bit of preventative maintenance is to whip off the inner plastic arch liners (front and rear) periodically, and clear away any crud built up behind them. They tend to trap dirt and grime over time which then holds moisture next to the metal.
https://www.youtube.com/watch?v=nC93lggP9BM
When did the Volkswagen Transporter T5 come out?
Year of production: 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014 NOTE: Fuses F1-F7/F11/F12 – During assembly these fuses may be fitted in alternative positions, depending on vehicle specification.
What are the dimensions of a VW Transporter?
VW Transporter T5 LWB high roof Dimensions External dimensions. VW T5 Width including mirrors 2297mm. VW T5 Width excluding mirrors 1904mm. VW T5 External Height 2477mm. VW T5 External length 5304mm
How often should water pump be changed on VW Transporter T5?
If you are looking to buy a T5 it is worth asking if the job has been done on higher mileage examples. It is reasonably common for water pump failure on the 2.5 litre model VW T5’s. It is less common to see failure on the 1.9 as pumps should be routinely changed at 60,000 intervals (or every 4-5 years) alongside the cam belt.
What is the fault code for a VW Transporter?
Fault codes 16618 p0234 and has reduced power.on my 2006 transporter t32 2.5 tdi 174 bhp – Answered by a verified VW Mechanic We use cookies to give you the best possible experience on our website. By continuing to use this site you consent to the use of cookies on your device as described in our cookie policyunless you have disabled them. VW
What happens when the warning light goes out on a VW Transporter?
When the warning light goes out, you can continue your journey. If the warning light remains on, contact a Volkswagen workshop and do not continue driving. The spanner warning light may also illuminate indicating a fault with the dual clutch gearbox. The spanner warning light will flash intermittently with the gear selector display.
What does the red exclamation mark mean on a VW Transporter?
Warning lights also include VW Transporter variants such as the California, Caravelle, Shuttle and Sportline. The red exclamation mark is a potential brake system fault. The VW Transporter brake warning light comes on for the following reasons: 1. The parking brake is applied. 2. The brake fluid level is low.