How long does Volvo 940 fuel tank pump last?
Measuring the fuel pressure at the rail, crudely with a tire gauge, the same effect was seen – sometimes 25-30 lbs, other times about 5 lbs. This exercise is shown on a ’92 940 with 142K miles. The in-tank pumps seem to last perhaps 150k miles. Note similarities between the two tank pumps on the left:
How do you replace a fuel pump in a Volvo?
Put five more hose clamps onto the short section of new fuel injection hose, before sliding into it the brass splice tube. Then, slide the brass splice into one end of the fuel hose (that runs towards the engine) and also into the short length of fuel hose, that runs to the 90 degree brass elbow.
How do you disconnect fuel tank sender in a Volvo?
Then disconnect filler hose: To remove the Volvo quick disconnect fitting on the fuel outlet line (the 90-degree fitting below), grip the outer sleeve, and push that outer plastic cylindrical sleeve towards the top of the fuel tank send unit. Keeping the sleeve pushed “forward”, push the entire fitting towards the top of the tank.
What kind of clamps do I need for a Volvo fuel tank pump?
The large clamp holding the fill hose is Volvo p/n 943477-0; buy two of these. The smaller clamps are 943471-3; buy four of these. The spring clamps are 1321719-5; buy one of these unless you want to replace it with a screw clamp (recommended).
What do I need to know about my Volvo 940?
It’s a pretty general section, but very useful for servicing your Volvo 940 with the right service interval. This group contains the Volvo 940 service & repair manuals for the engines (redblock and diesel-engines), fuel injection systems and other engine components like the cooling system.
What causes a bad fuel pump in a Volvo?
Fuel Main Pump Problems & Replacement Gas More Than Empty But Can’t Be Pumped Out B230K BiFuel Engine Ticking Sound: Fuel Pump Fuel Tank: Gas Cap Fuel Tank Fill Hose Failure Fuel Tank Auxiliary Tank Fuel Pressure: Fuel Pressure Regulator and System Pressure Noisy Fuel Pump: Bad FPR Fuel Pressure Test Tool Failed Check Valve Abbreviations
How do you replace fuel pump sender in Volvo?
Tap gently against the sender unit’s top lip. Using steel on (old) plastic requires that you go slowly. The send unit will back out. Disconnect the sender wiring harness from the connector in the left side wheel well, then cut the zip ties holding the wire to the fill tube. Fish this harness out through the grommet hole near the fuel sender unit.
How many miles does a 920 tank pump last?
Measuring the fuel pressure at the rail, crudely with a tire gauge, the same effect was seen – sometimes 25-30 lbs, other times about 5 lbs. This exercise is shown on a ’92 940 with 142K miles. The in-tank pumps seem to last perhaps 150k miles. Note similarities between the two tank pumps on the left: Parts Needs.
Where is the fuel pump sender on a Volvo?
To remove the Volvo quick disconnect fitting on the fuel outlet line (the 90-degree fitting below), grip the outer sleeve, and push that outer plastic cylindrical sleeve towards the top of the fuel tank send unit. Keeping the sleeve pushed “forward”, push the entire fitting towards the top of the tank.
How do you replace a Volvo fuel tank pump?
Tighten all clamps (two on either side of the straight hose splice, and one where the spliced hose goes onto the 90-degree brass elbow. Then tighten the hose clamps on the short section of rubber hose around the send unit’s steel tube, and where that short section of hose, goes into the 90-degree elbow.
How do you change the fuel in a Volvo?
Shut off the engine and remove the keyfrom the ignition. Raise the car (740) high enough, so that you have the best of angles (and room to work) to hold all in proper position. Spray the fuel filter fittings with penetrating oil.