What kind of Turbo does a Volvo 850 GLT have?
This handy chart will help identify the turbo fitted to your vehicle: 13G : 97 Volvo 850 GLT, 98 S/V70 GLT, 98 V70 XC It’s important to know the exact model of turbocharger your vehicle has when shopping for a rebuild kit.
When to replace or rebuild a Volvo turbocharger?
Of course, bearing failure is always one of the top reasons for replacing or rebuilding a Volvo turbocharger. If the compressor wheel can be wiggled up and down, this is not immediate cause for concern unless it is excessive. Turbos are designed to allow slight motion in this direction, as oil flows between the shaft and the bearing.
Where does the oil go in a Volvo turbo?
P80 Volvos use a PCV system that recycles crankcase oil vapor into your turbo’s inlet, and circulates it through the intake tract in order to be reburned. This is normal, and not typically a cause for concern if oil is discovered in your intake piping.
What kind of engine does a Volvo P80 use?
As some of these cars are now approaching 20 years old, the seals in these turbochargers tend to become very brittle and cannot do their job well anymore. P80 Volvos use a PCV system that recycles crankcase oil vapor into your turbo’s inlet, and circulates it through the intake tract in order to be reburned.
What should I do about my Volvo 850?
Volvo 850 S70 V70 C70 automatic transmission service & repair manual 850 …………………………………….. AW50-42LE NOTE: Overhaul information or specifications are not available. In case of internal malfunction, manufacturer recommends replacing transaxle as an assembly. CAUTION: Vehicle is equipped with a Supplemental Restraint System (SAS).
How to identify a 1995 Volvo 850 transaxle?
For 1995 850, see the AIR BAG RESTRAINT SYSTEM article in the ACCESSORIES/SAFETY EQUIP section. Transaxle can be identified by identification plate attached to top of transaxle case. See Fig. 1.
How does DTC work on a Volvo 850?
If a transaxle problem exists, DTC (s) can be retrieved to determine transaxle problem area. Courtesy of Volvo Cars of North America. Throttle position sensor, mounted on throttle body, determines throttle position and delivers an input signal to TCM. TCM uses input signal for controlling transaxle upshifts and torque converter lock-up.
What are the lows and highs of a Volvo 850?
Moreover, there is a newfound edge to the steering—a tactile precision that betters the 850 Turbo wagon’s already exemplary feel. LOWS: Cruel rough-roads ride, potential visual trauma of a Volvo in yellow. Yet the low-profile Pirellis are costly in other ways.
What does the Volvo 850 T-5R look like?
The T-5R cabin resembles the squarish 850 Turbo interior—with embellishments. The already excellent leather seats feature extra side support, and the leather itself is trimmed with an actually handsome faux-suede material (it’s on the steering wheel and the center console, too). The audio system is plumped up with a robust amplifier.
Do you need a turbocharger on a Volvo?
Most Volvo owners agree it’s not uncommon to want a bit more power out of their reliable old Swede. Having a turbocharger fitted from the factory means you have flexibility in how you increase your engine’s power over stock levels. Or, you may have a turbo that is struggling to deliver your engine’s factory rated output.
https://www.youtube.com/watch?v=LfoJ8MuCwOY
What kind of Turbo do I need for Volvo S70 T5?
(The 15G and 16T have extremely similar flow characteristics, often unnoticeable in real world driving) As your stock turbo improves with each model, your stock upgrade options go down. An S70 T5 with a 16T would want to upgrade to an 18T or 19T.
How to change spark plugs on Volvo S70?
Get the various tools and spark plugs assembled and make sure you’ve got everything you need laid out. There is nothing time sensitive about this, so take your time. Use the Torx bit to remove the six bolts as shown below. Then remove the black cover. This is what the head looks like with the black cover off. You can see the five plugs.
How many spark plugs does a 5 cylinder Volvo use?
Volvo’s 5 cylinder engines take 5 spark plugs, and the debate rages as always as to whether Bosch Platinums are better than Champion or NGK. The safe route is OEM Volvo turbo 5-cylinder / non-turbo 5-cylinder or Champion RC8PYP. Do a Stage 0 before anything else.
What kind of outlet does a Volvo 850 have?
Conical outlet flange (94-95 850 turbo, 95 850 T5-R), straight outlet flange (96-97 850 R, T5 and GLT, 98 model S70 R, T5, And GLT), and angled outlet flange (All cars 99+ excluding the newer cars with KKK turbos).
When did the Volvo 850 platinum come out?
In 1996, a “Platinum” edition of the 850 Turbo was available. The exterior paint for these models came in a metallic pearl platinum-colour and had special 16 inch alloy wheels. The interior was fitted with leather seats and burled walnut accents. Only 1,500 of these were imported for the U.S. market.
What kind of Turbo does a HPT 850R have?
All HPT 850’s received TD04HL-15G turbos, with stock boost for turbo and T5 models set at 9.6 psi, and T5-R and R models at 10.5 psi (stock hp are 222 and 240, respectively). (The European manual transmission 850R received a 16T turbo)
What are the features of a 1994 Volvo 850?
The 1994 850 Turbo is able accelerate from 0 mph (0 km/h) to 60 mph (97 km/h) in 7.1 seconds. In terms of technical features, Volvo switched from 4 bolt to 5 bolt hubs, made ABS standard on all markets and introduced a new A/C system.
When was the last year the Volvo 850 was made?
The Volvo 850 is a compact executive car that was produced by the Swedish manufacturer Volvo Cars from 1991 to 1996.
When did the SIPS Bag come out on the Volvo 850?
Beginning with their 1995 model year, Volvo introduced the SIPS-Bag on the 850; these airbags were included as standard equipment on the 1995 Turbo models, and were optional for an additional $500 on other 850 models. This made the Volvo 850 the first mass-produced car in the world to feature the side-impact airbags.
When is it time to replace a Volvo turbo?
If you can push or pull on the shaft and notice any sort of bearing play, it is time to rebuild or replace. This is commonly called “In & out” play, and is a death sentence for your turbo if it is not corrected immediately. P80 Volvos arrived in the United States with six different turbochargers fitted from the factory.
What kind of turbocharger does a Volvo have?
These Volvos are referred to as the “P80” generation, and they all used physically interchangeable Mitsubishi TD04 turbochargers. Does your turbocharger look like this?
When did the Volvo 850 get side impact airbags?
This made the Volvo 850 the first mass-produced car in the world to feature the side-impact airbags. The SIPS became standard equipment for all new Volvo cars beginning with the 1996 model year. In 1995, the Volvo 850 was ranked the fourth-safest vehicle on the market by the Insurance Institute for Highway Safety.
What kind of interior does a Volvo 850 have?
Volvo 850 Interior. This shows 850 dash, driver’s seat, steering wheel and instrument cluster. And, this is a rare 850 5-speed manual. North American Debut of the 850. Volvo introduces the new 4-door wagon, which they’ll continue to produce until the 850’s demise.
When to replace turbo control valve in Volvo?
Please note that the Turbo Control Valve may not be the problematic component. However, TCV failure is common for vehicles over 10 years old or 100k miles. Often times, a failed TCV will store a code which can be read using a Volvo specific scan tool. What is a turbo control valve?
How much does it cost to rebuild a Volvo turbocharger?
It’s important to know the exact model of turbocharger your vehicle has when shopping for a rebuild kit. Rebuild kits typically range from $50-$150 depending on quality and quantity of parts included. As a do it yourself task, it is very rewarding, but leaves a high risk of screwing something up.
How do you replace a TCV in a Volvo?
Disconnect the electric push-release clip. If you are simply replacing the TCV, use pliers to disconnect the quick releases for the vacuum hoses, highlighted purple in the Volvo image below. Remove the hoses from the old TCV, and reconnect them onto the new TCV.
What kind of Turbo does a 2.0 LNF have?
The Stage 1 kit utilizes a K04 turbo as found on the 2.0 LNF. Our Stage 1 has instant spool and power at any rpm and adds approximately 80whp to your car. This turbo kit is capable of a lot more but it would require a higher flowing catback exhaust and a boost controller to turn up the boost.
Which is better 2.2L or 2.4L turbo kit?
This turbo kit is capable of a lot more but it would require a higher flowing catback exhaust and a boost controller to turn up the boost. Engine: If you select 2.4L then the kit will come with a higher bar MAP sensor.
Are there any problems with the 1993-2000 850?
Fortunately, the shift interlock micro-switch is fairly easy to replace. Many 1993-2000 850, S70, C70 and V70 models can have issues with the ABS control module that can cause the ABS warning lamp to illuminate.
What kind of maintenance does a Volvo 850 need?
1993-96 MAINTENANCE Volvo Maintenance Information 1993-96 850 Sedan 1994-96 850 Turbo Sedan 1995-96 850 T-5R Turbo Sedan 1994-96 850 Wagon 1994-96 850 Sportswagon 1995-96 850 T-5R Turbo Sportswagon * PLEASE READ THIS FIRST *
What kind of oil does a Volvo 850 use?
F (-20 C) Volvo oil (P/N1161001-1) (2) – DO NOT use Dexron fluid in manual transmissions. (3) – Use low pressure grease gun to prevent seal damage. (4) – Fill until lubricant squeezes out from the base of seals. (5) – Fill ball joint until seal starts to swell. FLUID CAPACITIES FLUID CAPACITIES TABLE
When to replace camshaft belt on Volvo 850?
Although some manufacturers do not recommend belt replacement at a specified mileage, others require it at 60,000-100,000 miles. A camshaft drive belt failure may cause extensive damage to internal engine components on most engines, although some designs do not allow piston-to-valve contact. These designs are often called “Free Wheeling”.
How can I tell if my Volvo 850 is leaking coolant?
Check the oil dipstick to see if the oil has mixed with the coolant, producing a milk-chocolate appearance. If this has happened, then the oil needs to be replaced immediately as well. Check the two heater hoses leading into the firewall where coolant is also known to leak on Volvo 850’s.
When did the Volvo 850 come to America?
Don’t underestimate the Volvo 850, the car that, in its characteristic Swedish reserved way, reinvented the automaker when it popped into American showrooms for 1993. The boxy 850 didn’t look like much of a departure, but Volvo’s investment in its new car was the most any Swedish brand had ever spent on itself.
Is the Volvo 740 Turbo still in production?
So the 760 Turbo was now the 940 SE, but a 940 Turbo model was also offered, which was basically a 940 SE without the multilink suspension. The 740 Turbo was still around, too. For the enthusiast, the 740 was the only turbocharged Volvo you could still get with a manual transmission by 1991.
What did Henry Miller say about the Volvo 740?
Henry Miller was long dead when Volvo introduced the 740 Turbo, but in “Tropic of Cancer” he described an erection as “light and heavy at the same time, like a piece of lead with wings on it.” Take that, Sociology Boy. The early Turbos have a black egg crate-style grille, while later models sport more aerodynamic front end styling.
When did the first Volvo 850 come out?
The 850 also introduced side impact airbags to the world. On top of all that, Volvo’s first dip into high performance vehicles came with the T-5R 850 in 1995, their turbo version of the 850.
What kind of transmission does a Volvo 850 have?
The engine was mated to a 4-speed automatic transmission or 5-speed manual transmission, the latter of which was not available in the United States.
What do I need to know about my Volvo 850?
For specifications pertaining to fluid capacities for the entire vehicle, fuse and circuit breaker identification, wheel and tire size, battery type, warranty information, or model identification refer to the MAINTENANCE INFORMATION article in this section. NOTE: See the AIR BAGS article in the ACCESSORIES/SAFETY EQUIPMENT Section.
When does service interval change on Volvo 850?
These designs are often called “Free Wheeling”. Many manufacturers changed their maintenance and warranty schedules in the mid-1980’s to reflect timing belt inspection and/or replacement at 50,000-60,000 miles. Most service interval schedules in this manual reflect these changes.
What’s the average speed of a Volvo 850 T-5R?
Mated to a slick-shifting electronic four-speed automatic (the only transmission offered), our T-5R wagon scorched to 60 mph in just 6.7 seconds—three-tenths quicker than our last 850 Turbo wagon.
Where can I find the Volvo 850 service manual?
Below you can find the complete service and repair manual for the Volvo 850. All subjects (actually it are the chapters of the 850 service manual) are seperated in a single webpage. Click on the item you want to view and it will open in a new tab/window. Seats (powered and heated) troubleshooting, diagnostics, wiring diagram & repair instructions
What’s the problem with my 1993 Volvo 850?
Just the little annoying things that can drive you nuts trying to resolve if you don’t know the cause and where to begin fixing it. Beginning with the 1993 850 Volvo began using an upper engine mount (also called the upper engine stabilizer) that helped to control engine movement especially during acceleration.
Is there a 2.0L version of the Volvo V70?
A 2.0L version of the V70 XC was available only for markets with high taxes on cars with an engine capacity of more than 2000 cc. Standard ride height was increased 35 mm (1.4 in) overall with 26 mm (1.0 in) more ground clearance compared to the regular AWD model.
When did the Volvo V70 Ocean Race come out?
V70 / XC70 Ocean Race. In 2001, to mark their sponsorship of the just renamed Volvo Ocean Race, special Ocean Race editions of the V70 and V70 XC were announced. Released for model year 2002, the cars came painted only in a unique shade of blue. Silver exterior trim and roof rails, as well as assorted badging,…
When did Volvo stop production of the V70?
Production of the V70 ended on 25 April 2016, the XC70 continued until 13 May 2016. The sedan model was called Volvo S80 . The first generation V70 was an improved development on the basis of the Volvo 850 estate.
Is it possible to upgrade a Volvo turbo?
TD04 turbos are very reliable, and if you find a dry example of one that has been well cared for, they tend to last a very long time, even at increased boost levels above stock. The upgrade route is easy, since there are only four options regardless of what you drive.
What kind of engine does a Volvo have?
Help, Advice and DIY Tutorials on Volvo’s extremely popular car line — Volvo’s 1990s “bread and butter” cars — powered by the ubiquitous and durable Volvo inline 5-cylinder engine. Quick history – ’94 850 turbo wagon, automatic. Bought the car as a project with a blown head gasket, and I have no idea what originally caused it.
What are the most common problems with 1993-2000 Volvos?
All 1993-2000 850, S70, C70 and V70 models (as well as most 2001 2007 S60, S80, V70 and XC 90 models) use a complicated crankcase vent system to prevent the build u of pressure inside the engine. Since the mid 70’s Volvo owners have had problems with this system clogging up with oil deposits.
How much does a 1997 Volvo T5 Turbo cost?
Monthly Estimate based on a 4.4% rate for 60 months, $3,988 vehicle price, $0 down payment, $0 trade-in, $0 sales tax. Good guys, honest and friendly.
How does the shaft of a Volvo turbo work?
The shaft, in essence, floats on a bath of fresh oil while it spins, and requires a slight 360º gap to give the oil room to flow through. As always, use good judgement (Check YouTube) when determining your turbo’s health – this play should be minimal.