Where is the gear selector on a 2006 S60R?
2006 S60R, auto transmission. No OBDII codes stored, info display reads ‘Gear Selector Service Required’. Tried a new GSM (Gear selector module, the circuit board that lives under the shift knob)- no change.
Are there any lights on the gear selector?
The lights on the shifter are never lit. the car shifts normally but with no geartronic function. The car behaves the same whether I plug the GSM in or leave it unplugged, and this the same with the original module.
What does tcm-dd01 stand for in gear selector module?
Year and Model: See Signature below. TCM-DD01 The communication lead between the gear selector module (GSM) and the transmission control module (TCM) is short-circuited to voltage or ground. Check the wiring between the GSM and the TCM.
What kind of gear selector does a Bosch Motronic use?
Check fuse F21 and check for shorts between Violet/White & Blue/White. 3/156 Gear Selector Module (GSM), 3/155 Mode selector, 8/36 Shift lock solenoid. 1998 C70, B5234T3, 16T, AW50-42, Bosch Motronic 4.4, Special Edition package.
What should I do if my transmission sensor has failed?
Place the shifter into a gear and attempt to start the engine up. If the engine starts with the transmission in gear, then the sensor has failed. Step 1: Park your vehicle on a flat, hard surface.
How to replace a transmission position sensor ( switch )?
Step 1: Take out the new sensor. Put the new sensor onto the transmission. Step 2: Install the mounting bolts to the sensor. Tighten them down hand tight. Torque the bolts to 8 foot-pounds. Note: Do not over tighten the bolts or you will crack the new sensor. Step 3: Plug in the harness to the sensor.
What to do if your Volvo has intermittent electrical problems?
Getting the CEM module replaced by the dealer costs $1000+. A cheaper solution would be to repair your existing module. Remove your existing module and send it for repair to a facility that offers Volvo CEM Module Repair on eBay. A CEM module (or corroded connections at CEM) trigger intermittent electrical problems.
Where is the CEM module on a Volvo?
Locate the CEM module under the dashboard on the passenger side for 2003 to 2013 models. In 1999 – 2004 XC90, XC70, V70, S60, S80 CEM is under the driver’s side dashboard. Remove the kick panel or fabric cover under the dash. You will need to remove plastic retainers to pull down the cover.