Where is the fuel pump on a Volvo S60?
The lower part of the backseat and backrest on the right side need to be removed. The pump is on the passenger side #2. You have to remove the retainer #6 to remove the pump. The PITA part is that a hose and the fuel pump wiring go inside the tank to the drivers side. You have to remove the retainer on the drivers side then the level sensor #4.
Can a defective fuel pump cause a S60 to not start?
Volvo S60 2004, Fuel Pump Module Assembly by Spectra Premium®. A defective fuel pump can cause a no-start condition or poor engine performance. If replacement is required, your best choice is Spectra Premium. All components are 100%…
What causes a bad fuel pump in a Volvo?
Fuel Main Pump Problems & Replacement Gas More Than Empty But Can’t Be Pumped Out B230K BiFuel Engine Ticking Sound: Fuel Pump Fuel Tank: Gas Cap Fuel Tank Fill Hose Failure Fuel Tank Auxiliary Tank Fuel Pressure: Fuel Pressure Regulator and System Pressure Noisy Fuel Pump: Bad FPR Fuel Pressure Test Tool Failed Check Valve Abbreviations
How do you remove the fuel sender in a Volvo?
To remove the panel covering the fuel sender in the wagon, push the rear seats forward, pull back the front floor panel, remove the three nuts holding the panel in place, and pull the panel up and forward to remove. It is secured by adhesive or Velcro and two clips that clear once it is pulled forward.
The ground point for the pumps and PEM is ring terminal under the rear seat cushion inside the passenger compartment, passenger side. Pump only pumps fuel from the right side of the car (I’ll avoid using driver or passenger side terminology for the sake of correctness).
Where is the PEM located on a Volvo S60?
The PEM was originally located under the car near the fuel tank, on most of them the PEM was relocated into the trunk while still under warranty. Because of this the wiring looms back there probably look a little complicated/crazy.
Where is the fuel pump control module located?
In earlier cars, this module will be located in the passenger’s side front wheel well. It was relocated to beneath the rear seat on later model cars due to water based failure rates. Hope this was helpful! Please like and subscribe so I can get that sweet sweet beer money back! Loading…
Is the fuel pump on the driver’s side of the tank?
It’s a 12V feed and if yours is the type with the connector at the top of the pump it’s dead easy to use a piercing probe on the 12V and chassis wires. The pump works it just doesn’t pump from the driver’s side of the saddle type tank. this tank can be completely empty on one side and full on the other side.