Are there any problems with the Volvo D16 engine?
This thread is for owners of Volvo D16 engines. A number of driver’s are having problems with this engine. I and several other D16 owners want to gather information as to the problems you may have experienced with this engine for a possible class action lawsuit. Every month 400 people find a job with the help of TruckersReport.
What’s the difference between a Volvo D12 and D13?
D12 was only an EGR engine for emissions. The later D13 used DPF/SCR and likely ran hotter, so likely they made some changes. The D-16 started out as a 625hp engine in the Cowboy truck.
Is the D16 engine the same as the ISX?
Also the D16 uses the exact same turbo as the Cummins ISX and they themselves are feeling this problem. bigbyrc Thanks this. Actually holset is the builds the turbo the the housing and design are entirely volvo’s. Thats why the isx engine dosent have the same problem.
Why is my Volvo truck not accelerating forward?
I have 2006 Volvo and I when I press the gas pedal there is no acceleration. I already checked and replaced the relay sensors but that wasn’t the problem. I also checked and replaced the pedal sensor but the truck still wont accelerate. The engine turns on, my truck is on, it just wont accelerate forward. It says to check the light modular.
What kind of engine does a Volvo vnl64t780 have?
Single vertical exhaust, grill guard bumper, double bunk with work station. 2018 VOLVO VNL64T780, 2018 VOLVO VNL64T780. D13 ECO-TORQUE 455HP WITH ISHIFT TRANSMISSION EQUIPED WITH PREMIUM DASH MOUNTED SHIFT SELECTOR AND HILL START ASSSIST, DAVCO 382 FUEL FILTER (HEATED), ENG…
What kind of brakes does a Volvo D13 have?
Engine Equipment: Air Compressor, CFM Two Cylinder, 31.8 Retarder Volvo Engine Brake (VEB) Engine Brake Rating at 2200 rpm 500 hp @ 2200 rpm Engine Brake Rating at 1500 rpm 350 hp @ 1500 rpm Engine Brake Weight, lbs. (kg) 25 (12) PTO Port for Live Rear PTO Pump or Shaft Standard on VHD Preheater, Electrical Optional
How much does a Volvo D13 engine weigh?
Air Compressor, CFM Two Cylinder, 31.8 Retarder Volvo Engine Brake (VEB) Engine Brake Rating at 2200 rpm 500 hp @ 2200 rpm Engine Brake Rating at 1500 rpm 350 hp @ 1500 rpm Engine Brake Weight, lbs. (kg) 25 (12) PTO Port for Live Rear PTO Pump or Shaft Standard on VHD Preheater, Electrical Optional * Application at 6 mpg or greater. 3
What kind of lube does a Volvo D13 use?
Total Lube Oil Capacity, qts. (L) 38 (36) Oil Filtration Two Full Flow, One Bypass Oil Drain Interval, Normal Service, miles (km) 55,000 (88,514)* Oil Specification Volvo VDS-4.5, SAE 10W-30 FLOCS Oil Drain Kit Optional Engine Equipment: Air Compressor, CFM Two Cylinder, 31.8 Retarder Volvo Engine Brake (VEB)
https://www.youtube.com/watch?v=6rOIt6iajfY
Why does my Volvo stall at idle RPM?
If the problem only occurs when the A/C is on, there is an issue with the compressor. If the battery is run down and the alternator is working hard to recharge it, the increases load on the engine may pull down the idle rpm to the point where it causes the engine to stall.
What’s the top rev limit on a Volvo?
This is a very common failure, that normally starts as an intermittent fault causing the engine to run in ‘limp home mode’ this restricts the vehicle to around 30 MPH and a top rev limit of no more than 3 thousand revs until the ignition is cycled again.
How long does it take to rebuild a Volvo throttle body?
We can rebuild this Volvo throttle body within 1-2 working days and return it to you with an unlimited mile lifetime warranty. Using our bespoke Hardware-In-the-Loop test rigs each Volvo throttle body is tested under real-world load and driving conditions.
What is the fault code for a Volvo truck?
Reset ABS Faults, Body Controller Faults and more. 1 Volvo Link System Faults (MID 142) Fault Code Description FMI MID 142 PID 155 Input 1-4. 2 Vehicle ECU Faults (MID 144) 3 Climate Control Faults (MID 146) 4 Light Control Module Faults (MID 216) 5 Gear Selector Module Faults (MID 223)
What is FMI 0 on a Volvo dryer?
FMI 0 The pressure in the air suspension receiver is above normal. The compressor discharge valves in the compressor head are faulty, the wiring of the compressor discharge solenoid valve in the dryer is damaged. Damaged, dirty or clogged compressor discharge valve in the drier.
Which is better Volvo D16 or 15 litre?
The Volvo D16’s larger displacement gives it advantages over existing 15-litre engines, said officials. The larger bore (or diameter) of the D16’s cylinders gives the tops of its pistons more surface area. This means it can generate more power and torque than a 15-litre engine, with lower internal forces.
What makes a Volvo D13 engine so good?
There is also a version of the D13 engine that utilizes turbo compounding technology, which allows the vehicle to deliver plenty of power with less fuel. With turbo compounding technology, your vehicle will utilize condensed air to produce more power while maintaining greater fuel efficiency.
What’s the difference between Volvo D13 and Cummins X15?
As something of a heavier engine, the Cummins X15 ups its power ratings slightly. Horsepower ranges from 400 to 500. However, torque remains the same as in the D13. It also employs bigger block architecture, so you can get peak torque at lower engine speeds.
Is there no acceleration on a 2006 Volvo?
Discussion in ‘ Volvo Forum ‘ started by EddieBellVolvo, Aug 6, 2015 . I have 2006 Volvo and I when I press the gas pedal there is no acceleration. I already checked and replaced the relay sensors but that wasn’t the problem.
What kind of engine does a Volvo D-13 have?
Air Ride Suspension; 77 in Raised Roof Sleeper; Yes Engine Brake; Aluminum Wheels; 252 in Wheelbase; BLUE Color; Tandem Axle; VOLVO D-13 1800RPM 1750 LB-FT XE Volvo Engine 455 hp; Automatic OD; Diesel Fuel Type; 34,000 lb Rear Axle Weight; Drive Side: Left Hand Drive; VIN #: 4V4NC9EH7FN912401; BR…