Where do I find the T444E code on my school bus?
Call your local IH dealer and ask them for a list of codes and get yourself a copy of the engine diagnostic manual. You will probably need it later. start with the first code,check cables at battery,there are 2 smaller cables attached with inline fuses,they get corroded.
When did the Navistar T444E IDI engine come out?
The T444E replaced the 7.3 IDI that was produced between 1982 and 1993, and is an all new engine with essentially no parts in common. It featured an turbocharger with a charged air cooler, hydraulic electronic unit injection (HEUI), and was all electronically controlled.
When did the Ford T444E engine come out?
The T444E is one of the most popular engines found in school buses between 1994 and 2004. This engine was used as the base platform for Ford’s 7.3 Powerstroke as well, sharing almost all mechanical components. The T444E replaced the 7.3 IDI that was produced between 1982 and 1993, and is an all new engine with essentially no parts in common.
Are there any problems with the Ford T444E?
The T444E has had oil leak problems from day one, although most are resolved now, but it doesn’t seem to matter since it’s now out of production altogether. The DT-466 will continue to improve over the years and will only get better.
Is the T444E the same as the DT?
We have run the T444Es since they were first introduced, as well as the “NGD” versions of the DT. We see about an even mix of 444s and DTs, and have yet to replace/overhaul a T444E because they are NOT wet-sleeve engines.
How often do you have to adjust the valves on a T444E?
Most of the O/H are around the 250K miles. Lots of problems with the valve stems beaten down. You now have to adjust valves once a year or 2000 HR.
What’s the trouble code for a 1995 dt466e?
That is good for 1995-1999 DT466E engines. Good Day! I’ll sticky this for you guys…. I can also post the newer engine DTC lists if you would like. If you could post the trouble codes for the later DT466E i would appreciate it. I have ordered the Intl. CD Manual but would like to start on the codes in my 2002 truck.
What’s the code for a DT 466E diesel truck?
We got couple of 05 International truck that has VGT problem. Code 152 (BAP signal out of range low). 354 (VGT control under duty cycle) and Body Controller – Remote Engine Speed Control #1 – Analog input #2 shorted to ground. Already replace BAP sensor, MAP sensor and VGT turbo.
When to warn Engine Lamp on DT 466E?
*- Indicates WARN ENGINE LAMP on when fault is set. That is good for 1995-1999 DT466E engines. Good Day! I’ll sticky this for you guys….