What causes a Saab 93 convertible soft top failure?
The tailgate is also closed. The problem arises when you press the button to fold the roof down. The back of the roof (rear window section) releases and comes up about 1-2 inches and goes no further, along with a warning display on the SID unit stating ‘SOFT TOP FAILURE’. I imagine its not going to be anything to serious!?!?! Any suggestions???
How to put a top up and down manually on a Saab 9-3?
How to put a top up and down Manually on a Saab 9-3 Convertible? The convertible version of the second-generation 9-3 began with the MY04, in the previous generation, a roof raising system were switch to an hydraulically operated convertible top instead of electric.
Is there a convertible version of the Saab 9-3?
The convertible version of the second-generation 9-3 began with the MY04, in the previous generation, a roof raising system were switch to an hydraulically operated convertible top instead of electric. With one and with the other system there were problems, but slightly more problems with this hydraulic.
What causes a Saab 9-3 throttle body to fail?
location: Fitted to the top of the inlet manifold Throttle body failure for Saab 9-3 and 9-5 vehicles is very common. Internal component malfunction of the Saab throttle body will cause running symptoms including poor start, especially on cold mornings, erratic/poor idle and serious power loss.
Where is the soft top on a Saab?
When the soft top is open, it is covered by the soft top cover and stored in a space between the rear seat and the luggage compartment. The soft top is opened and closed using a hydraulic system controlled by the STC (Soft Top Control).
How to repair a Saab 9-3 convertible roof?
METHOD.. you will need a pozi screwdriver a 13mm socket or adjustables, a small stick and a bottle of lucazade for some energy to get to the three 13mm rusty nuts in the boot.
Where is shear pin on Saab 9-3 convertible?
On the 9-3 (not the new one) there is a small shear pin, which will shear to prevent damage in the event of an obstruction. Open the boot, and undo the bolts keeping the trim on the top edge (facing you, where the boot hinges are located.
Why is my Saab 9 3 convertible roof not working?
My 10 plate stopped mid cycle once and blew a fuse, leaving roof half open. Replaced fuse and no probs since, so suggest check fuses under bonnet. firstly, dig out the owners handbook and find the section on fuses/fusebox and check the fuse for the roof is OK. also check if the relay is clicking. May be the relay and or fuse has burnt out.
Is there a warranty on a Saab 9 3?
I’ve got a two and a half year old Saab 9 3 Convertible, there’s no warranty available anymore since SAAB UK went into administration and it’s not working. The SID display says that only manual operation is available. The rear heated windscreen button lights up for a minute if that when I turn it on then goes off.
Where is the fuse box on a Saab 9-3?
Control module, engine management system; DICE/TWICE; main instrument panel/SID; memory for electrically operated driver’s seat; telephone; cruise control Under the instrument panel next to the steering wheel. Fuse panel in engine bay.
How much does a stealership for a Saab cost?
FYI we also run a MR2 convertible and the differences in price between a stealership and good independent can be vast. had a 02 sensor fail, the stealership wanted £53.00 just to diagnose this, with the 02 sensor and resetting the fault codes it would have cost £330.00.
Can a Saab convertible top hydraulic cylinder be rebuilt?
Rebuilding and upgrading hydraulic system components for your First Generation Saab 9-3 or Saab 9-3 Viggen Convertible – Top Hydraulics’ quality is unmatched!
How to put a top up and down Manually on a Saab 9-3 Convertible? The convertible version of the second-generation 9-3 began with the MY04, in the previous generation, a roof raising system were switch to an hydraulically operated convertible top instead of electric.
The convertible version of the second-generation 9-3 began with the MY04, in the previous generation, a roof raising system were switch to an hydraulically operated convertible top instead of electric. With one and with the other system there were problems, but slightly more problems with this hydraulic.
Where is the soft top mechanism located on a Saab cabriolet?
The hydraulic cylinders are located one on each side. The sixth bow (9) joint is located where the soft top mechanism (12) is mounted to the body and is operated and secured by two hydraulic cylinders, one on each side. The sixth bow is made of aluminium.
What are the bows on a Saab cabriolet?
Between the right-hand and left-hand metal rails are six bows. The bows are numbered from one to six with the front bow closest to the windscreen numbered one. The first bow (1) is made of magnesium in one piece with the front rails.
Why is my Saab 9-3 door lock not working?
The central locking door lock mechanisms on Saab 9-3s (and 9-5s) are known to occasionally malfunction/stop working. When you hit the central locking button on the remote, the affected door often won’t lock (or won’t unlock if it was already locked). The issue tends to start out intermittent and then worsen with time.
What to do if your Saab convertible wont close?
(Saab Convertible: Close the door and soft top.) 2. Open the fuse box. To open the case, it must be pushed a bit in direction to the front wheels and than opened as the white part of the picture in shows. Reset the pinch protection by removing and fitting fuse F5 from the instrument panel electrical centre (IPEC).
Why are my electric windows on my Saab not working?
Electric windows can be extremely convenient, but when they don’t work, it can become a very frustrating and expensive problem. If your driver window (it also applies to all other windows) decided to go back down to about 2/3, guess it’s the Pinch protection feature .
The central locking door lock mechanisms on Saab 9-3s (and 9-5s) are known to occasionally malfunction/stop working. When you hit the central locking button on the remote, the affected door often won’t lock (or won’t unlock if it was already locked). The issue tends to start out intermittent and then worsen with time.
What makes a Saab 9-3 convertible a bad car?
A couple of dings in the bodywork which due to their location would be difficult to pull, hole in the drivers mat caused by a high heel, every alloy had kerbing, o/s wheels were particularly bad & the rear was corroded to hell, tyres had plenty of tread but the rubber was perishing and cracking. All in all not a good morning
Why does my Saab 9-3 make a popping noise?
SAAB 9-3 Binding Steering and Popping Noise From Suspension (Broken Coil Springs) Broken suspension springs are a common problem in new-gen 9-3’s, and are something to keep an eye out for. For whatever reason, the springs snap near the perch, causing a knocking/popping noise.
Where is the door card on a Saab 9-3?
To access the door locking mechanism, we need to remove the door card and disconnect some cabling etc. There are two screws holding the door card in place, both located under the inner handle. You need to carefully prise the handle apart to access them: The two screws have Torx heads, you’ll need a long driver to reach the middle one.
I’ve got a two and a half year old Saab 9 3 Convertible, there’s no warranty available anymore since SAAB UK went into administration and it’s not working. The SID display says that only manual operation is available. The rear heated windscreen button lights up for a minute if that when I turn it on then goes off.
The tailgate is also closed. The problem arises when you press the button to fold the roof down. The back of the roof (rear window section) releases and comes up about 1-2 inches and goes no further, along with a warning display on the SID unit stating ‘SOFT TOP FAILURE’. I imagine its not going to be anything to serious!?!?! Any suggestions???
(Saab Convertible: Close the door and soft top.) 2. Open the fuse box. To open the case, it must be pushed a bit in direction to the front wheels and than opened as the white part of the picture in shows. Reset the pinch protection by removing and fitting fuse F5 from the instrument panel electrical centre (IPEC).
Why does my Saab 9-3 crank but not start?
If your 9-3 isn’t getting enough fuel, or any fuel at all, it may have a bad fuel filter, bad fuel pump, or bad fuel injectors. Without the proper amount of fuel getting into the combustion chamber, the 9-3 will crank, but not start. 2. Ignition Issues One of the biggest issues that causes a vehicle to crank but not start is ignition issues.
Where is the scissor jack on a Saab 93?
On the right hand side, inside the rear wing, remove the carpeting, and you will see an arrangement that looks like a scissor jack.
Is there a problem with my Saab 9-3 Turbo?
I have a 2002 Saab 9-3 turbo the car was running but when I stepped on the gas it would die out and fall on his face I replace the fuel pump in the fuel filter and the car does not want to start at all stay running any idea what the problem may be
Why does my 2001 Saab won’t start?
My 2001 saab won’t start sometimes or even turn over. All the gauges and the radio come on but that’s it and now my buttons on my key won’t even work and there is a dinging sound that won’t go off while the door is open and the light doesn’t dim ON when you pull the key out of the ignition ( it used to do this) Any ideas of what is going on?
Why does my Saab 9-3 run after 100k miles?
crank sensor probably needs to be replaced. If your car starts up and runs after it’s cooled down, but cuts off again after engine has warmed up, then more then likely it’s your crank shaft sensor. They tend to go out on the 9-3s after 100k miles. I just replaced mine for preventative maintenance. 10 people found this helpful.
What to do when your convertible top stops working?
By the time your convertible top stops working, the leaks should be easy to identify. Inspect the hydraulic lines. Make sure they are tightly connected. The hoses should not be cracked or leaking. Address any leaks that you may find at the pump, cylinders, or solenoid. Replace any damaged or leaking o-rings.
Rebuilding and upgrading hydraulic system components for your First Generation Saab 9-3 or Saab 9-3 Viggen Convertible – Top Hydraulics’ quality is unmatched!
What’s the warranty on a Saab convertible top?
Top Hydraulics’ standard warranty is 3 years on rebuilds/upgrades of convertible top cylinders and hydraulic pumps, and on new hydraulic hoses.
What kind of hydraulics does a Saab 9-3 use?
Top Hydraulics is the leading manufacturer of replacement hoses for your Saab 9-3 cabriolet hydraulics – far exceeding OEM specs, and hoses are always in stock. Rebuilding and upgrading hydraulic system components for your First Generation Saab 9-3 or Saab 9-3 Viggen Convertible – Top Hydraulics’ quality is unmatched!
What is the sealing layer on a Saab 9-3 cabriolet?
The sealing layer is used as a moisture barrier. Sewn along the sides is a drip moulding to prevent water droplets falling onto the seats when the doors are opened. The roof is folded over the edge of the first bow and is fastened with double-sided adhesive tape and riveted plastic rail.
Why does soft top not work on Saab convertible?
And just by a coincidence did this appear, quote: ” If the soft top storage is not at its lowest position, the control module will not operate the soft top but will send a bus message, after which the Saab information display (SID) will show: “Soft top blocked. Remove obstruction and try again”, meanwhile an acoustic signal will be heard. ”
Where is the sensor on a Saab convertible?
This sensor is a part of the soft top storage and detects the lowest position of the “tray”. The switch is located on the soft top bag drive mechanism, to the left of the “wire reel”; follow wire to its black connector.
Is the roof on a 1998 Saab 93 Convertible?
A collegue of mine has just purchased a 1998’R’ Saab 93 2.0i SE Convertible. Unfortunatly, the roof seems to have developed an inability to open (it opened when the car was collected). The windows go down to the set 20cm, the roof aperture within the boot compartment is not obstructed, nor is it hooked up.
Where are the bows on a Saab soft top?
As the soft top opens, the mechanism folds at these hinges and at the main point of rotation (12), i.e. where the soft top mechanism is fastened to the body. Between the right-hand and left-hand metal rails are six bows. The bows are numbered from one to six with the front bow closest to the windscreen numbered one.