How to replace the air conditioning in a 2002 Honda CRV?
Once the radiator and condenser are removed, the Keihin HS110r compressor is pretty much staring you in the face! According to the 2002 Honda service manual this is how to replace the compressor: 1)If the compressor is marginally operable, run the engine at idle speed, and let the air conditioning work for a few minutes, then shut the engine off.
What is the shop manual for a Honda CRV?
The 2002 CR-V Shop Manual is divided into 23 sections. The first page of each section is marked with a black tab that lines up with its corresponding thumb index tab on this page. You can quickly find the first page of each section without looking through a full table of contents.
How do you remove interior trim on a Honda CRV?
1. Fold up the rear seat. 2. Detach the hooks (A) from the cargo area side trim panel (B) and B-pillar lower trim (C), and pull the rear door sill trim (D) up by hand to detach the clips (E, F). 3. If necessary, pull the rear side outer trim (G) up to detach the clips (H, I), then remove the trim.
What kind of car is 2002 Honda CRV?
Recently we purchased our youngest daughter a 2002 Honda CRV with 79,000 miles on it thinking we bought a “good” vehicle for her. The lady we purchased it from was a school teacher and the nice looking SUV looked to be well taken care of.
When do I get the Honda CRV owner’s manual?
Delivery time is approximately five weeks. To save paper and time, you can download the latest manuals now. Recommended Service for Your 2002 Honda CR-V Recommendations for regular servicing tasks for your vehicle can be found in Service & Maintenance .
How do you remove a transmission from a Honda CRV?
The best way to remove the electrical connectors is NOT to break the tabs on them with a screw driver. Instead, use your meaty hands to squeeze the tab until it clicks, then stick a flatblade screwdriver between the two connectors and twist. Most of the connectors will be pretty seized up.
What is the part number on a Honda CRV?
The Honda part number is 18393-SH3-S00. The nuts are probably too rusty to work with, so replacing them is not a bad idea. They are part number 90212-SA5-003. Disconnect the two electrical connections of the exhaust, then remove the bracket holding them on.
Where is the first page on a Honda CRV?
The first page of each section is marked with a black tab that lines up with its corresponding thumb index tab on this page. You can quickly find the first page of each section without looking through a full table of contents.
Why was my Honda CRV air conditioner blowing up?
Though this ’02 Honda CR-v isn’t a classic, I felt compelled to put this repair on Classic Cars and Tools because there are many people out there having problems with this particular AC system (including yours truly), mainly due to the HS110R scroll AC compressor blowing up!
What to do if your Honda CRV air conditioner is not working?
The only remedy is to replace the entire air conditioning system. If you own a Honda CRV and are experiencing problems with your air conditioning system, you may need to have the entire system rebuilt instead of just replacing the compressor. It’s more expensive, but it can save you the time and expense of having repeated failures.
Are there any recalls on the Honda CRV?
Honda CRV air conditioning systems are notorious for failure, but there isn’t an actual AC recall. Honda owners are left with a service bulletin and talk of the “AC black death.” Honda CRV air conditioner recall-related issues include: Service bulletin for A/C Compressor clutch Numerous complaints about A/C failure Honda Black Death
How does a bad AC compressor affect your car?
Every air conditioning system of a vehicle depends on a steady flow of refrigerant to circulate through it. This refrigerant is what allows the air conditioner to produce the cool air which comes out of the vents in the dashboard. Let’s find out the symptoms of bad AC compressor how it affects the AC system.
What should I do if my AC compressor is failing?
If any of the interior components break, or the compressor’s internal bearings fail or seize, then all sorts of noises can be produced as a result. The most valuable solution is changing the whole AC compressor.
Once the radiator and condenser are removed, the Keihin HS110r compressor is pretty much staring you in the face! According to the 2002 Honda service manual this is how to replace the compressor: 1)If the compressor is marginally operable, run the engine at idle speed, and let the air conditioning work for a few minutes, then shut the engine off.
Though this ’02 Honda CR-v isn’t a classic, I felt compelled to put this repair on Classic Cars and Tools because there are many people out there having problems with this particular AC system (including yours truly), mainly due to the HS110R scroll AC compressor blowing up!
Where is the compressor on a Honda CRV?
Changed Relay lasted 3 weeks now compressor fail. Compressor is located in the worst possible place what a piece of ****!! 7 people found this helpful. I know these posts are older it’s probably a little late for us but we’ve had to replace our 2002 crv ac 5 times and cost us a tone of money.
Is the AC compressor on a Honda CRV under warranty?
Other Honda models are each known for different weaknesses and it’s the compressor for CR-V. Lucky for my wallet at least the first time was under certified warranty with somewhere around 54,000 miles. Second time the compressor’s clutch somehow led to it’s demise.
How often should you change the battery in a Honda CRV?
The video above shows you how to replace the battery in your 2006 Honda CR-V. We recommend changing the battery in Hondas every 4 years.
How to get the radio back on a Honda CRV?
In some CR-Vs, you may need to re-enter a security code to get your radio to work again. Check for this code in your owners manual – it will usually be either a sticker or small card in the booklet. If you can’t find it, call Honda and they will give you the code for free.
How to replace an A / C line or hose?
Wear other personal protective equipment (PPE) when necessary, for example latex gloves or closed toe shoes. Open the hood and locate the vehicle’s A/C lines or hoses. Disconnect the negative battery cable using an open ended wrench. Recover any refrigerant (discharge A/C system) with an A/C machine. Remove damaged A/C lines or hoses.
How to replace a negative battery in a car?
1 Open the hood and locate the vehicle’s A/C lines or hoses. Disconnect the negative battery cable using an open ended wrench. Recover any refrigerant (discharge A/C system) with an A/C machine. Remove damaged A/C lines or hoses. Install the new o-rings, A/C line, and hose. Reconnect negative battery cable.
Can a Honda CRV air conditioner be self diagnosed?
You may be able to save a lot of time and money by trying to troubleshoot car problems yourself. Air conditioning problems are quite common, and might be caused by any number of things. Try to self-diagnose air conditioning problems in your Honda CR-V.
Where is the blower motor on a Honda CRV?
Find the blower motor in a Honda CR-V by prying of the lower foot panel on the passenger’s side. Unplug the electrical connectors and pull the blower motor downward.
Where is the blower motor on my Honda CRV?
The Fan does not work either on the AC or the heater. I check the fuses both under the hood (left side engine area) and under the dash (right side steering column. All fuses were good.
Is there a warranty on my Honda CRV?
The service bulletin was issued in July 2013. It extends the warranty on the air conditioning system to seven years or 100,000 miles on the 2007-2011 CRV. Since this period is over, it isn’t helpful to Honda CRV owners with current A/C issues. Honda CR-Vs are known for their air conditioning systems failing.