Why does my Mercedes Benz Vito not start?

It could be a few things really Camshaft sensor Fuel line seals Injectors fault Lift pump or High pressure fuel pump My guess is its a seal in the fuel lines maybe the one that seals the return line from the fuel rail..

What to do with a Mercedes Vito camshaft?

Try using easy start to start it one morning give it a spray and then turn it over. if it goes then it could be as simple as the fuel line seals but could also be the fuel pumps. If you need any other help check out Your one stop shop for all your mercedes vito New and Used parts and spares or give me a shout on the number on the site Mark

When to diagnose a problem with a Mercedes?

The failing ones will warn you via an ever-growing vibration in the steering wheel and passenger cabin. To prevent the Mercedes problems of mounts, you should diagnose them regularly after 80,000 mileage or 7 years. 2. Mercedes Won’t Start The Mercedes starting problems will make the engine crank but refuse to start.

Why does my Vito air blower keep getting warm?

Vito Aircon issue! Whenever I turn the Aircon ON, by switching the dial button (compressor), instead of getting cool air, the air coming from the aircon vent were warm as if I just turn the blower on without running the compressor.

Are there any problems with the Mercedes Vito?

Questions about Mercedes-Benz Vito Answered One of the common problems to occur with the Mercedes-Benz Vito is failure to start. This can be attributed to many reasons. It may take a fair amount of troubleshooting to arrive at the exact cause.

Why does the Mercedes Vito go into limp mode?

Why does the Mercedes Vito van (112 CDI 638 chassis) go into limp mode after climbing over a long hill or while under load? The vacuum transducer and turbo pressure sensor were changed. There are a variety of reasons which can result in the Mercedes Vito engine going into a limp mode.

How to remove the spare tire on a Mercedes-Benz Vito?

What is the procedure to remove the spare tire on the Mercedes-Benz Vito AA3CDI? To remove the spare tire on the Mercedes Benz Vito, first the retaining nut needs to be undone using a wheel nut spanner. Typically there are two nuts beside each other. One needs to be removed only a little while the other needs be undone completely.

I suppose if injector or common rail (if it has it) pressure is down then possible not enough fuel is getting into the engine to ignite. Try this: Turn key to last position before starting, wait for coil light to go out. Turn off again, then turn back to the same position, wait about 15sec then try starting again.

Why does my Mercedes diesel engine not start?

However, if the engine is not running correctly automatic regeneration will not be started. Some of the possible causes are a faulty temperature sensor, swirl flap motor or EGR valve. Also, make sure you only use approved engine oil. Wrong engine oil can cause excessive soot build up.

Why are the glow plugs on my diesel engine not working?

Glow plugs are an essential component for a cold start of every diesel engines. These are, in essence, a strong electrical heaters. As the car ages the glow plugs can fail. The symptoms are a long cranking time and a very rough running in the first several minutes.

What causes soot build up in Mercedes engine?

Wrong engine oil can cause excessive soot build up. Luckily, the regeneration process can be initiated manually, using an appropriate diagnostic tool. In most cases, this will purge a clogged DPF. Mercedes, like many diesel cars, uses a DPF Exhaust Pressure Sensor to determine how much does the DPF restrict the exhaust flow.

Why does my Vito 109 05 not start?

I have a vito 109 05 plate I. Went on a road trip ..starting running fine ..called at a friends ..about ten mins n then put key in all sounded good turn key engine trying to star but wont any idea’s please people as I have no idea Click to expand… So the starter motor is turning the engine but the engine not starting?

What should I do if my Mercedes Benz won’t start?

Start the car and you should be able to get around 60 psi. When the engine is running and when you turn off the engine the pressure should stay steady. Always perform this test on a cold engine. Next, make sure that the fuel injector connections are secure and not loose. Check the fuel pump and the fuel pump relay.

What happens when Mercedes diesel engine is not running?

As Mercedes DPF traps and holds soot, with time it reaches a point when it needs to be ‘emptied out’. This is done by regeneration. During this automated process, engine computer rises exhaust gasses temperature over 630°C. This burns up soot particles. However, if the engine is not running correctly automatic regeneration will not be started.

However, sometimes when I try to start the vehicle (normally within approx 20 minutes of turning it off), the engine will either turn over but not fire or, will turn over and fire but not start. In all cases, the engine turns over without a problem so I don’t think it’s the starter motor.

Is there a problem with my Vito long?

Vito Intermittent Starting Problem ! I have a 2004 111CDi Vito Long with 76K miles and have been experiencing intermittent starting problems for about a month. In the morning it starts first time and I can invariably stop and start several times during the day without the problem.

How much does a Mercedes Benz Vito cost?

It’s got low kays, long reg and new tyres, all factors in its favour. Assuming it’s a regular diesel van the value would be $8000-$10,000. Along with the flood of imported passenger cars we’ve seen in the last decade or so has come a wave of imported light commercial vans. With them has been the Mercedes-Benz Vito, a semi-bonneted van …

Is there a recall on the Mercedes Vito?

The Vito van has been under scrutiny for failing to meet the emission laws, and Mercedes has been ordered to recall them. Show the dealer your record of reports and battery replacements to back up your claim and request a goodwill payment to cover the cost of replacing the alternator.

Why does my Mercedes Benz take so long to start?

In all cases, the engine turns over without a problem so I don’t think it’s the starter motor. Invariably, if I wait from between 5 to 10 minutes (without attempting to start the vehicle) the vehicle will start first time but today it took half an hour (and many attempts) to get it started.

Is the Mercedes Benz Vito a real car?

With them has been the Mercedes-Benz Vito, a semi-bonneted van THE MB100 was built by SsangYong when Mercedes-Benz was getting up close and personal with the South Korean carmaker. It had a Benz badge, but it wasn’t of the same quality as a real Benz. I wouldn’t like to split the Vito and Transporter.

What’s the problem with the Mercedes Vito 111?

Mercedes Vito 111, W639 2008 Model, 6 speed gearbox, 90k miles. The problem I had, as do many it seems – is that from a standing start, engine running, first gear is hard to select, and on some occasions requires some extreme force to shift the lever into position 1.

Is there a problem with Mercedes Vito gearbox?

Having read all the horror stories regarding Mercedes Vito gearbox problems I was intent of getting to the bottom of this problem as all I had read on the internet about ‘suggestion A’ and ‘suggestion B’ etc. all seemed contradictory and to be honest there was little to substantiate any of the writing. So here we go….

Why does my Vito car not start up?

If it starts with a Sniff of Easy, Then its likely to be your High pressure fuel pump. Really you need it plugging into STAR to see the Live data of the fuel rail pressure, it needs to be 225+psi to start up! Also this would show if it was camshaft/crankshaft syncronization fault.

Why did Mercedes Benz take the Vito off the market?

From there, you can take a much more targeted approach to working out which of the hundreds of possible components is causing the problem. Don’t forget the basics, either, such as contaminated or old fuel in the tank. Modern fuel doesn’t like sitting around in a tank and can `go off’ over time. Why have Mercedes-Benz taken the Vito off the market?

Navigation