How long will a Mercedes Sprinter diesel last?
300,000 miles
In fact, with a diesel engine, a Sprinter will easily see a lifespan of over 300,000 miles. As long as you stay on top of regular maintenance, the longevity of a Mercedes Sprinter will serve you well. But these vans are not devoid of some major common issues, and these problems are expensive to repair.
How can I tell if my Mercedes Sprinter has a problem?
A quick and dirty test to indicate any problems with the variable vanes is to remove the air box or air filter housing and listen as the engine is revved. Once the engine is started, the vac actuator rod should move down slowly as vac builds, this in turn should apply force to the lever moving the vanes into a fully charged position.
What was the model year of the Mercedes Sprinter?
Sprinters up to model year 2006 share some similarity with the later model when it comes to ‘mysterious’ cutting-out and repeated intermittent non-start issues, this article covers specifically the earlier 4 cylinder Sprinter >2006, although some of the items covered are also common to the later model.
What to do if your Mercedes Sprinter has a split pipe?
Check vac supply to this device observing and rectifying any split or leaking pipework. Once good vacuum supply has been determined, with the ignition off (no power to the valve and no vacuum present) the route of vacuum should be blocked by the valve to the turbo actuator.
What causes a sprinter to cut out and not start?
For the most part the electrical system will be the major cause of any none or poor starting issue. There are two main timing sensors fitted to the engine: Crank Position Sensor and Camshaft Position Sensor.
What was the problem with my Dodge Sprinter?
I have two 2003 3500 Dodge Sprinters that I’ve had since new. Both have approxmatly 150K miles on them. The first one developed a loss of power around 125K and the problem was traced to leaking fuel injectors around the seal for the injector and caused replacement of head, all injectors and injector seals. The dealer replaced these items.
Is the Check Engine light on on a MB sprinter?
The new MB Sprinters in USA have check engine light systems that actually tell you why they come on. In pretty much all cases you CAN DRIVE WITH THE LIGHT ON. Just make sure that your OIL-LIGHT IS OFF and you will be just fine.
Can a Dodge Sprinter start in cold weather?
My Dodge Sprinter 2007 will not start in extreme cold weather (-30F). (14400km) Took it to the dealer they installed a circulation heater in the heater hose (1000W). Again the Sprinter would not start in minus 30F weather after the heater was installed.
What to do when your Dodge Sprinter spins?
If it spins easily and/or does not stop spinning very quickly, then the fan clutch is spent and a new fan clutch is needed. 4) restart the engine right away and let idle (or drive again) to let the engine oil cool down a little (and the turbo to cool off).