How do you remove a Prius battery?
How to Disconnect Hybrid Batteries
- Make sure the vehicle is turned off. Remove the key from the ignition before you attempt to disconnect the battery.
- Prop open the hood and remove the liner, if necessary. Remove any paneling and covering over and around the battery.
- Disconnect the negative cable from the battery.
What kind of battery does a Toyota Prius use?
Numerous safeguards have been designed into the PRIUS +/PRIUS v to help ensure the high voltage, approximately 201.6 Volt, Li-ion Hybrid Vehicle (HV) battery assembly is kept safe and secure in an accident. The PRIUS +/PRIUS v utilizes the following electrical systems:
What happens when you stop a Toyota Prius?
qDuring deceleration, such as when braking, the vehicle regenerates kinetic energy from the front wheels to produce electricity that charges the battery assembly. rWhile the vehicle is stopped, the gasoline engine and electric motor are off, however the vehicle remains on and operational. PRIUS +/PRIUS v Identification -2-
When did the Toyota Prius Hybrid come out?
In March 2012, Toyota released the PRIUS +/PRIUS v gasoline- electric hybrid vehicle. To educate and assist emergency responders in the safe handling of the PRIUS +/PRIUS v hybrid technology, Toyota published this PRIUS +/PRIUS v Emergency Response Guide. The PRIUS +/PRIUS v is based on the 3rdgeneration Toyota PRIUS.
What kind of power steering does a Toyota Prius use?
An Electric Power Steering (EPS) assist motor rated at 27 Volts. High voltage electrical safety remains an important factor in the emergency handling of the PRIUS +/PRIUS v Hybrid Synergy Drive.
Remove the battery hold down, a bar across the top of the battery. There is a 10 mm bolt on one side and a 10 mm nut on the other; take them both out and remove the hold down. It will be easier to remove the negative terminal from the car body rather than from the battery.
How to remove high voltage battery from Prius?
High Capacity 38 Gen II Cells Newer in Age Improved Design Around $800 Follow Safety Procedures Safety Glasses Properly Insulated Gloves (1KV) Remember Acid Is Corrosive! Summarized Removal Procedure Key Off Disconnect 12V Battery Remove HV Disconnect Plug Trunk/Left Side of HV Assembly
How big is the battery in a Prius?
Front Bus Bar Connects Positive Side Rear Bus Bar Connector Splits Negative Side Negative Side Connected by Relay ›System Main Relay (SMR) Divides Battery 28 Cells 201 Volts Static About .75” Longer High Capacity 38 Gen II Cells Newer in Age Improved Design Around $800 Follow Safety Procedures Safety Glasses
Where is the bus bar on a Prius?
Uses Bus Bar Small Wires Connected at Each POS Block Terminal 1 Connected to NEG Bus Bar 17V #1 Block 14.6 #10 Block On One Restart Voltage Fell Off Graph HV Battery Bad? Decided to Upgrade to Gen II Cells 38 Cells = 273.6 Static Volts 2 Cells = 1 Block 19 Blocks Front Bus Bar Connects Positive Side
https://www.youtube.com/watch?v=y9JbVstPGcw